Accuphase-DP77-sacd-sm维修电路图 手册.pdf

《Accuphase-DP77-sacd-sm维修电路图 手册.pdf》由会员分享，可在线阅读，更多相关《Accuphase-DP77-sacd-sm维修电路图 手册.pdf（26页珍藏版）》请在收音机爱好者资料库上搜索。

1、Bi-lingual Attention mark indicating critical components for safety. Replacement must be made with identical parts of special part number. 部品、安全上重要部品。 必指定部品番号部品使用下。 These servicing instructions are for use by qualified personnel only. To reduce the risk of electric shock do not perform any servicing

2、 other than that contained in the operating instructions unless you are qualified to do so. Refer all servicing to qualified service personnel. 記載関指示事項、関資格 有者使用。感電防止観点、資格 有方、取扱指示事項以外絶対行 下。 CAUTION / Authorized Technical Service Only 回路図 RadioFans.CN Side Panel (139-0035-22) Push-button for POWER (38

3、8-5044-03) Power Switch Assembly Assy (726-0143-00) Power Switch (354-1024-00) Front Panel Assembly Assy (130-0169-01) Front Glass (172-0116-03) Foot 脚 (238-0023-00) Knob (383-1201-03) Decoration Screw 飾 (630-0304-14) Washer (637-9045-04) Sub Panel /not supply (134-0138-03) Bottom Plate (155-0078-02

4、) Top Plate Assembly Assy (150-0069-12A) Top Plate(B) B (150-0053-03) EXPLANATION OF SURFACE PARTS Push-button /5-gang /5連 (388-5059-13) Tray Sub-panel (134-0130-04) Sub Panel (134-0138-03) mark parts not supplied Knob (383-1201-03) TraySub-panel (134-0130-04) Binding Screw /4pcs. (604-0408-00) Wash

5、er 平/4pcs. (637-0042-07) Panel End-cap (132-0098-04) RadioFans.CN FRONT VIEW(前面) REAR VIEW(面後) Pin Jack /2pcs. (302-0116-00) Pin Jack Cover /4pcs. (254-2015-04) Foot 脚 (238-0023-00) Square Plate (159-0069-14) XLR (Cannon) Plug Receptacle /2pcs. (301-8005-00) Connector Cover /Male /2pcs. (254-2011-00

6、) AC Inlet AC (301-3306-00) Power Supply Cord 電源 J type:680-1404-00 U,T type:680-2401-00 E type:680-3402-00 Rear Panel (135-0158-02) Front Panel Assebly Assy (130-0169-01) 1Front Panel=131-0169-01 2Sub-panel =134-0138-03 3Tray Sub-panel=134-0130-04 4Push-button/5-gang=388-5059-13 /5連 5Decoration Scr

7、ew=630-0304-14 飾 5-1 Washer=637-9045-04 5-2 Nut=633-2032-02 六角 6Front Glass=172-0116-03 1pce. 1pce. 1pce. 1pce. 2pcs. 2pcs. 2pcs. 1pce. 6Display Assembly=723-0081-00 Assy 6-1 Fixed Bracket=159-0097-03 化粧板 6-2 Rubber Cussion=250-2140-04 6-3 Filter=179-0029-04 7Push-button=388-5044-03 /POWER 7-1 Push-

8、button Frame=113-0100-14 7-2 Coil Spring=285-1016-04 7-3 E-ring=647-1054-00 E 8Panel End-cap=132-0098-04 1pce. 1pce. 1pce. 1pce. 1pce. 1pce. 1pce. 1pce. 2pcs. 1 2 6 5 437 2 Decoration Screw 飾/4pcs. (630-0302-04) Washer (637-9045-04) Pin Jack /2pcs. (302-0116-00) Pin Jack Cover /4pcs. (254-2015-04) O

9、ptical Rceiver /IC4 (GP1FA513RZ) Knob (383-1201-03) Binding Serew /脚用 /414 (611-0414-02) Optical Rceiver /IC2 (GP1FA513TZ) 88 RadioFans.CN SACD Kit /SACD Mechanical Assembly Assy (731-0007-00) TOP VIEW BOTTOM VIEW (底面) AC Inlet / Line Filter AC (301-3306-00) IO Assembly IO Assy (726-0142-00) Metaliz

10、ed Polyester Capacitor C001:0.01F/250V (CF99MF2E103M) Fuse for 100-120V T1.25A L 250V (310-1104-00) Fuse for 220-240V T630mA L 250V (310-1061-00) Attention mark indicating critical components for safety. Replacement must be made with identical parts of special part number. 部品、安全上重要部品。 必指定部品番号部品使用下。

11、DAC Assembly DAC Assy (725-0041-00) DSP Assembly DSP Assy (724-0055-00) Power Transformer (510-4031-00) Power Switch Assembly Assy (726-0143-00) Mother Board Assembly Assy (726-0144-00) Power Transformer (510-4032-00) Power Transformer (510-4031-00) SACD Kit /SACD Mechanical Assembly Assy (731-0007-

12、00) DAC Assembly (725-0041-00) Power Transformer (510-4032-00) Mother Board Assembly Assy (726-0144-00) Main Board Assembly Assy (1-679-080-12) *This assembly is contained in SACD Kit. *Assy SACD 含。 RF Board Assembly RF Assy (1-679-092-11) *This assembly is contained in SACD Kit. *Assy SACD 含。 Power

13、 Push Switch /POWER (354-1024-00) Terminal 端子板 (313-4046-00) RadioFans.CN FRONT VIEW Sub-chassis side Power Switch Assembly Assy (726-0143-00) Power Push Switch SACD kit /SACD Mechanical Assembly Assy (731-0007-00) Rotary Encoder / S6 (339-0006-00) Push-button (388-5044-03) Frame (113-0100-14)Push-b

14、utton /5-gang /5連 (388-5059-13) Explanation of Front-panel back view mark parts not supplied Display Assembly Assy (723-0081-00) Front Glass (172-0116-03) Filter (179-0029-04) Display Tube 蛍光表示管/FL1 (434-0013-00) Push Switch /S15 (354-1116-00) Main Board Assembly Assy (1-679-080-12) Display Assembly

15、 Assy (723-0081-00) Infrared Receiver 赤外線 /IC2 (NJL64H380A) Rotary Encoder / S7 (339-0008-00) Rubber Cushion (250-2131-04) Fixed Bracket 化粧板 (159-0097-03) RadioFans.CN MISCELLANEOUS(本体他使用部品) No. C001 Packing Material 梱包材 Description PC Board for DSP Assy DAC Assy IO Assy Mother Board Assy SACD Kit /

16、 RF Board /RF Main Board /Assy Optical Pick-up /光 Switch Assembly /Assy Loading Motor / Belt / FuseT1.25A L 250V T630mA L 250V M e t a l i z e dP o l y e s t e r Capacitor Outer Carton Box 箱 Top Pad (F) F Top Pad(R) R Bottom Pad(F) F Bottom Pad(R) R Top Board /天地当板 Cover /保護 Accessories Case /付属品 Wr

17、apping Sheet / Bagfor AC Cord,Remote, Audio Cord Poly Bag /袋 for Manual Cover /保護for Remoote Part No. 115-1436-00 115-1438-10 115-1439-10 115-1441-10 731-0007-00 1-679-092-11 1-679-080-12 8-820-132-03 1-641-764-11 1-641-765-11 4-927-649-01 310-1104-00 310-1061-00 CF99MF2E103M 801-0243-14 803-0324-00

18、 803-0325-00 803-0326-00 803-0327-00 803-0033-14 810-4843-04 801-0251-10 810-4545-04 810-2030-04 810-2030-04 812-2435-04 810-1030-00 Remarks not supplied KHM-230AAA/J1RP for 100-120V for 220-240V 0.01uF/250V (前) (後) (前) (後) (本体) AC, 取説用 Inner用 No. Screws for 類 Accessories 付属品 Description(部品名) Front

19、Panel /用 Binding Screw / Top Plate Assy / Round Head Screw / Binding Screw / Side Panel / Oval Head Screw /丸 Binding Screw / Washer / Bottom Plate / Binding Screw / Foot / 脚用 Binding Screw / Option Slot Panel/ Decoration Screw /飾 Washer / Power Transforer/用 Binding Screw / Spring Washer / Owners Man

20、ual 取扱説明書 Notes 注意書 Power Supply Cord(J type) 電源(U,T type) (E type) Remote Commander Battery / 電池 Audio Cord (L)/ Audio Cord (R)/ Pin Jack Cover / Connector Cover for male Part No. 631-0047-00 616-0306-02 631-0054-00 612-0308-00 604-0408-00 637-0042-07 631-0054-00 611-0414-02 630-0302-04 637-9045-04

21、 604-0408-02 638-0041-02 820-2213-00 820-0213-00 821-0011-00 821-0010-00 680-1404-00 680-2401-00 680-3402-00 729-0028-00 569-0006-00 685-0416-10 685-0417-10 254-2015-04 254-2011-00 Remarks 38mm6pcs. 36mm6pcs. 310mm2pcs. 38mm4pcs. 48mm4pcs. 4mm dia. 4pcs. 310mm9pcs. 414mm4pcs. 4pcs. 4pcs. 48mm8pcs. 8

22、pcs. English Japanese English Japanese 2-conductor 2-conductor 3-conductor RC-28 R03 /UM-4/単4 White /1m Red /1m 4pcs. 2pcs./出力用 SACD Laserdiodens specifikationerLaserdiodespecifikationerLaserdiode-spesifikasjonerLaserdiodin ominaisuudet *Material:GaAlAs*Materiale:GaAlAs*Materiale:GaAlAs*Materiaali:G

23、aAlAs *Vglngd:780nm*Blgelngde:780nm*Blgelengde:780nm*Aallonpituus:780nm *Laseruteffekt:28.5uW*Laserudgangseffekt:28.5uW*Laserutgangseffekt:28.5uW*Laserin teho:28.5uW Laserdiodens specifikationerLaserdiodespecifikationerLaserdiode-spesifikasjonerLaserdiodin ominaisuudet *Material:AlGalnP*Materiale:Al

24、GalnP*Materiale:AIGalnP*Materiaali:AIGalnP *Vglngd:650nm*Blgelngde:650nm*Blgelengde:650nm*Aallonpituus:650nm *Laseruteffekt:73.7uW*Laserudgangseffekt:73.7uW*Laserutgangseffekt:73.7uW*Laserin teho:73.7uW CD CAUTION-INVISIBLE LASER RADIATION WHEN OPEN AVOID EXPOSURE TO BEAM CLASS 1 LASER PRODUCT KLASS

25、E 1 LASER PRODUKT LUOKAN 1 LASERLAITE KLASS 1 LASERAPPARAT VARNING-LASERSTRLNING NR DENNA DEL AR PPNAD STRLEN R FARLIG VARO!-AVATTAESSA OLET ALTTIINA LASERSTEILYLLE L KATSOSTEESEN BETRAKTA EJ STRLEN ADVARSEL-LASERSTRLING VED BNING UNDG UDSTTELSE FOR STRLING ADVARSEL-LASERSTRLING NR DEKSEL PNES UNNG

26、EKSPONERING FOR STRLEN Please perform lens cleaning of an optical pickup by air blow. The cleaning in a swab etc. causes failure. 光行下。 綿棒故障原因。 RadioFans.CN SACD Kit(731-0007-00) Including Main Board Assy See page 10. Mechanical Assembly (731-0007-00M) Assy Disc Table(4-948-353-18) /not supplied Opti

27、cal Pick-up(8-820-132-03) Belt(4-927-649-01) not suppled It does not need to be adjusted at the time of this machine performing part exchange etc., since automatic adjustment is performed for every disk. 本機毎自動調整行為、部品交換 行際調整必要。 、衣服人体帯電静電 荷等電位差生、静電破壊生危険。 修理時充分注意行下。 The laser light of this machine is c

28、ondensed so that a focus may be connected in the shape of a reflective side with the object lens in an Optical pickup. Therefore,when you check luminescence of a laser diode, please look aside more than 30 from an object lens. 本機光、内対物 反射面状焦点結集光。従、 発光確認時、対物30以上目 離下。 Handling needs to keep in mind tha

29、t a flexible printed circuit board tends to go out. * When there is the necessity for solder, perform solder iron point temperature before and after 270 degrees C. * Please do not apply the solder iron point to * same pattern to be careful repeatedly for power not to join a pattern. 基板切易取扱注意必要。 必要時先

30、温度270前後行。 力加注意必要 同一何度先当下。 The laser diode of an Optical pickup has a risk of pro- ducing potential difference in electrical charged on clothes or the human body, and producing Static electricitydestruction. At the time of repair, be carefully and carry out. Switch Assembly (1-641-764-11) Assy Loadin

31、g Motor (1-641-765-11) RF Board (1-679-092-11) Optical Pick-up (8-820-132-03) A cam is turned counterclockwise strongly. 反時計方向強回。 Remove the holder. / 外 A Disc table is pulled out, 4 screws is removed and a Optical Pickup is removed. 引出。固定 、外交換 A, B Two connectors are removed. A,B 所外。 A B Holder / D

32、isc Table / Solder is removed from a pattern land. 除 Insulator Screw / (2.6X8) Stopper / Cam / IMPORTANT 重要 The parts of this mark are not supplied. 部品供給 Caution / 注意 Up RadioFans.CN IC3CS8404A-CS IC4TC74VHCT04AF IC5,6TMS57070FFT IC7427-0010-10 ICIC7S-80845CLY IC8CS8427-CS/REVA2 IC9M93C46-BN6 IC10TM

33、P87PH00N IC101TC74HC00AF IC201TC74VHCU04F Variable/D101,102HVM17 Capacitance Diode Ferrite BeadsBK1608HM601-TFB1,2 CeramicC110,2124CK725B1E223M16T0.022uF/25V CapacitorC25,26,101,201CG14Y1C103MS0.01uF / 50V 磁器C34,35,111CK92Y5V1H104Z0.01uF /50V C36,37CK14B1H102KS0.001uF/50V C50,51CC14SL1H470JS47pF/ 50

34、V C105,107CC14CH1H680JS68pF/ 50V C106,108CC14CH1H4R7KS4.7pF / 50V ElectorlyticC11,28,104,109,110CE04W0J471VR470uF /6.3V CapacitorC27,29CE04W0J470SR47uF/6.3V 電解C102CE04W1H2R2SL2.2uF / 50V Polyester FilmC30,31CQ922M1H103J-B0.01uF /50V CapacitorC32CQ922M1H682J-B6,800pF/50V C33CQ922M1H104J-B0.1uF / 50V

35、Polyester FilmC103CF922N1H224JMTFF2.2uF /50V Capacitor Carbon FilmR1RD142CA101J1001/6W ResistorR2,105,108RD142CA471J4701/6W 炭素被膜抵抗器R4RD142CA470J471/6W R6RD142CA242J2.4k 1/6W R7,9,10,1418RD142CA473J47k1/6W R8,106,109RD142CA103J10k1/6W R11RD142CA332J3.3k 1/6W R13RD142CA472J4.7k 1/6W R2022,24,3135RD142

36、CA221J2201/6W R23RD142CA100J101/6W R30RD142CA331J3301/6W R101,103RD142CA102J1k1/6W R102RD142CA393J39k1/6W R104,107RD142CA105J1M1/6W Resistor ArrayRA1RD92AK05C473J18 抵抗RA2RD92AK16C473J18 RA3RD92AK13C473J18 RA4RD92AK04C473J18 RA5RD92AK09C473J18 DSP Assembly (724-0055-00) IC SocketSOCKET1300-1104-00 IC

37、 Connector PlugK1308-1402-00 K3,4308-0905-00 K903308-0707-00 K904308-0306-00 Connector JackK2307-3001-00 K901307-1607-00 CrystalIC11425-0015-00 水晶発振器IC12425-0016-00 水晶振動子XTAL101527-0038-00 水晶振動子XTAL102527-0039-00 XTAL3527-0025-00 Choke CoilL1507-4705-00 TransistorQ12SC3113-B Q1012SC982TM FETQ22SJ105

38、-GR,Y K2 K1 Q1 IC10 IC3 IC4IC5IC6 IC201 IC9 K903 K901 K904 K3 IC101IC8 IC11 XTAL101XTAL102 IC12 IC7 K4 SOCKET1 IC7 IC1 LPF1 X1K1 IC2 IC3 IC5 JK1JK3 IC4 Pin JackJK1,3302-0116-00 Connector PlugK1308-0707-00 Choke CoilL1507-4705-00 Low Pass FilterLPF1520-5005-00 ICIC1,3TC74HCU04AF IC5TC74VHCT04AF Opt-t

39、ransmitterIC2GP1FA513TZ Optical ReceiverIC4GP1FA513RZ Digital TransistorX1RN1202 Ceramic CapacitorC1,6CK92FJ1H474Z0.47uF /50V 磁器C2CK92Y5V1H104Z0.1uF/50V C4,8,9CG14Y1C103MS0.01uF /16V Electorlytic Capacitor C3,5,7CE04W0J470VR470uF /6.3V 電解 Carbon Film ResistorR1RD142CA241J240 1/6W 炭素被膜抵抗器R2,3RD142CA1

40、01J100 1/6W R4RD142CA473J47k 1/6W R5RD142CA104J100k1/6W R7RD142CA221J220 1/6W R8RD142CA222J2.2k1/6W Metal Film ResistorR6RN142CK75R0F751/6W 金属被膜抵抗器 IO Assembly (726-0142-00) RadioFans.CN Heat Sink240-1061-04 XLR(Canon)JK2,3301-8005-00 Plug Receptacle Pin JackJK1,4302-0116-00 Connector PlugK1,2,10230

41、8-0304-00 K3308-1402-00 K101308-1013-00 K103308-0508-00 K104308-0606-00 K701308-0905-00 IC ProtectorF16310-8251-00 IC RelayRELAY1,2,3362-0202-00 LEDD1,2TLS262-C DiodeD5,6LN1VB60 D11,108,109,112,113MA165 D101,102,103S1VB60 D104,105D4SBS4 D110,111EK03 Zener DiodeD7,8,9,10RD3.0EB1 D106HZ332L D107RD7.5F

42、-B TransistorQ1,2,3,42SA1316-BL Q5,62SC3421-Y Q7,82SA1358-Y Q1012SA1048-GR ICIC1,2,3ISO150AU IC4,5,6,7PC817-B/C IC8,9,101TC74VHC14F/EL IC10,11,12,13AD1853JRS IC14,15,18,19NJM4580D-D IC16,17NJM2114D IC20,22NJM78M05FA IC001UPC2412AHF IC002UPC2405AHF IC003,005UPC29M33HF IC004UPC24M05AHF IC006UPC2408AHF

43、 IC007UPC7908AHF DAC Assembly (725-0041-00) Ceramic CapacitorC1,2,3,6,100,103,104,105CG14Y1C103MS0.01uF/16V 磁器C7,8,9,10,15,16,17,18CK725B1E223M16T0.022uF/25V C1922,2730CC92CH1H221J220pF/50V C85,86,221227,229CK92Y5V1H104Z0.1uF/50V C11,12,13,14CE04W1C560LXY56uF/16V C23,24,25,26CE04W1E100VR10uF/25V C31

44、,32,81,84,91,92CE04W2C100RE310uF/160V Electorlytic CapacitorC45,46,55,56,57,58CE04W1C101PZ100uF/16V 電解C67,68,95,97,98CE04W2C4R7RE34.7uF /160V C73,74,75,76CE04W1C222VR2,200uF/16V C77,78,79,80CE04W1E561LXV560uF/25V C87,88,89,90CE04W1H100CA10uF/50V C101,211215,218,219CE04W1C101CA100uF/16V C201,202CE04W

45、1E332CZ3,300uF/25V C203,204,205CE04W1A682VR100uF/16V C206CE04W1H101VR100uF /50V C207,208,209,210CE04W1C332VR3,300uF/16V C216,217,220CE04W1H100VR10uF/50V Polypropylen CapacitorC3340CQ93PP2A332JM-F3,300pF/100V C41,42,43,44CQ93PP2A331JM-F330pF/100V C61,62,65,66CQ93PP2A471JM-F470pF/100V Polyester Film C

46、apacitorC4754CQ922M1H101K-B100pF/50V C93,94CF922MF2E473KD-AZ0.047uF/250V 積層C228CF922N1H104J0.1uF/50V PPS Capacitor/PPS C63,64CQ922M1H471JAHS470pF / 50V Carbon Film ResistorR1,2,3,4RD142CA391J3901/6W 炭素被膜抵抗器R58,6770,9194RD142CA102J1k1/6W R9,10,11,13RD142CA221J2201/6W R12,14,15,8790RD142CA101J1001/6W

47、R21,22,23,24RD142CA151J1501/6W R25,26,107RD142EA102J1k1/4W R37,38,39,40RD142EA182J1.8k 1/4W R43,44,63,64,65,66RD142EA470J4701/4W R45,46,71,72,73,74RD142CA103J10k1/6W R75,76,77,78,79,80RD142CA222J2.2k 1/6W R81,82RD142CA332J3.2k 1/6W R83,84,85,86RD142CA470J4701/6W R101RD142EA682J6.8k 1/4W R102,104,105

48、RD142EA101J1001/4W R103RD142EA104J100k 1/4W R106RD142EA183J18k1/4W R108RD142EA335J3.3M 1/4W R109,110,111,112,113RD142EA472J4.7k 1/4W Metal Film ResistorR17,18,19,20RN142CK2701F2.7k1/6W 金属被膜抵抗器R27,28,29,30RN142EK6340F6.341/4W R3136,41,42RN142EK2001F2k1/4W R4754RN142EK4991D4.99k 1/4W R5562RN142EK5111D

49、5.11k 1/4W IC8 RELAY2 IC11 K101 IC003 K102K103 JK1 JK2 RELAY3 Q101 IC100 IC101 IC001 IC002IC007 IC12 IC13IC22 IC004IC005IC006 JK4 JK3 RELAY1 K2K1K3 IC10IC14 IC18 IC16 IC15IC19IC17IC3 IC2 IC1 K701 K104 IC20 F16 RadioFans.CN Power Switch Assembly (726-0143-00) Assy Fuse HolderFH1,2306-2001-00 Connector PlugK1308-0236-00 Power Push SwitchS1354-1024-00 電源 Metalized PolyesterC1CF99MF2E103M0.01uF/250V Capacitor Mother Board Assembly (726-0144-0