Cambridge-640CV2-cd-sm维修电路图 手册.pdf

《Cambridge-640CV2-cd-sm维修电路图 手册.pdf》由会员分享，可在线阅读，更多相关《Cambridge-640CV2-cd-sm维修电路图 手册.pdf（44页珍藏版）》请在收音机爱好者资料库上搜索。

1、Gallery Court Hankey Place London SE1 4BB UK Tel: +44 (0)20 7940 2200 Fax: +44 (0)20 7940 2233 640C V2 Issue Date: 30th November 2005 Revised Date 1st Issue: 20th November 2006 _ SERVICE MANUAL _ SPECIFICATIONS: D/A Converter Dual Wolfson WM8740 24-Bit/192kHz capable Filter 4 Pole Dual Differential

2、Double Virtual Earth balanced Frequency Response (+/-0.1dB) 20Hz 20kHz THD 1Khz 0dBFs 0.0010% THD 1Khz -10dBFs 0.0005% THD 20Khz 0dBFs 0.0070% IMD (19/20 kHz) 0dBFs 24 kHz) 90dB S to N ration, A weighted 104dB Total correlated jitter 160pS Crosstalk 1kHz -100dB Crosstalk 20kHz -99dB Output impedance

3、 50 ohms Dimensions (H x W x D) 70 x 430 x 310 mm Weight 4.6kg (10.1lbs) AP19501/2 1 RadioFans.CN 640C V2 SERVICE MANUAL Revision 2 TABLE OF CONTENTS Safety Precautions furthermore the manufacturer cannot accept responsibility for personal injury or property damage resulting therefrom. 6. When servi

4、cing, care should be taken to observe the original routing and dressing of the leads and it should be confirmed that they have been returned to normal after re-assembly. Notes on chip component replacement Never reuse a component that has been removed from a PCB Notice that the minus side of a tanta

5、lum capacitor may be damaged by heat COPYRIGHT NOTICE. 2006 Audio Partnership PLC. All rights reserved. Cambridge Audio and Azur are registered trademarks for Audio Partnership PLC. This document may not be reproduced, distributed, transmitted, displayed, published, or broadcast without the express

6、written prior permission of Audio Partnership PLC. Alteration or removal of any trademark, copyright, or other notice from this content is prohibited. Information provided in this document is provided solely for the use of official service agents in repairing and servicing Audio Partnership PLC prod

7、ucts. 3 RadioFans.CN LASER SAFETY PRECAUTIONS Caution: These labels may be attached to the unit on the rear and inside to inform that it contains a laser component. Use of controls or adjustments, or performance of procedures other than those specified within the service or instruction manual may re

8、sult in hazardous radiation exposure. WARNING!WARNING! 1. Service should only be performed by qualified personnel. 2. This equipment has been designed and manufactured to meet international safety standards; it is the legal responsibility of the repairer to ensure that these safety standards are mai

9、ntained. 3. Any repairs must be made in accordance with the relevant safety standards. 4. It is essential that safety and EMC critical components are replaced with Cambridge Azur approved parts only. CLASS 1 LASER PRODUCT NOTES ON HANDLING THE OPTICAL PICK-UP BLOCK OR BASE UNIT The laser diode in th

10、e optical pick-up block may suffer electrostatic breakdown because of the potential difference generated by the charged electrostatic load, etc. on clothing and the human body. During repair, pay attention to electrostatic breakdown and also use the procedure in the printed matter which is included

11、in the repair parts. The flexible board is easily damaged and should be handled with care. NOTES ON LASER DIODE EMISSION CHECK The laser beam on this model is concerated so as to be focused on the disc reflective surface by the objective lens in the optical pick-up block. Therefore, when checking th

12、e laser diode emission, observe from more than 30cm away from the objective lens. 4 RadioFans.CN 5 RadioFans.CN Cambridge Audio Azur 640C V2 CD Player AP175163 Front Panel PCB Schematic SW1 PLAY/PAUSE SW2 STOP SW3 OPEN/CLOSE 1 2 CN1 CONN-H2 SEG11 16 SEG10 15 SEG9 14 SEG8 13 SEG7 12 SEG6 11 SEG5 10 S

13、EG4 9 SEG3 8 SEG2 7 SEG1 6 SEG0 5 COM3 4 COM2 3 COM1 2 COM0 1 SEG12 17 SEG13 18 SEG14 19 SEG15 20 SEG16 21 SEG17 22 SEG18 23 LCD1 LCD PACKAGE=LCD D600 1 2 3 4 5 6 7 8 CN2 CONN-H8 1 2 3 4 5 6 7 8 CN3 CONN-H8 1 2 3 4 5 6 7 CN4 CONN-H7 R3 27K R4 33K R5 2K7 R6 10K R7 82K R8 1K5 R9 82K C1 100n 50V X7R +5

14、V C2 1n 50V X7R C3 1n 50V X7R R10 68K R11 3K3 +5V FORWARD SKIPFORWARD SEARCH BACKWARD SKIPBACKWARD SEARCH SW4 SW-TACT SW5 SW-TACT C4 100n 50V X7R R15 100R VSS 14 RB2 11 RC4 6 RC2 8 RC3 7 RB1 12 RB4/OSC2/CLKOUT 3 RB0 13 VDD 1 RB5/OSC1/CLKIN 2 RB3/MCLR/VPP 4 RC5/TOCKI 5 RC1 9 RC0 10 U3 PIC16C505 SW6 S

15、W-TACT P1 PAD P2 PAD R12 4K7 R13 10K Q2 BC327 +5V 1 2 3 CN5 CONN-H3 1 2 3 CN6 CONN-H3 1 2 3 4 5 6 7 CN7 CONN-H7 C6 10uF 10V EL R14 220R Q1 BC337 K1 K2 +5V PWR DET RESET R1 220R R17 5K6 R18 2K2 +5V Q4 BC337 R19 4K7 1 2 CN8 MCLK_LOCK C5 10U 16V EL R2 5K6 R20 82R R16 4k7 +5V D1 1N5819 2 CCW 1 CW 3 R21

16、100R D2 LED 3MM BLUE +5V 3 OPT 1 GND 2 U2 IR REC 3/5V 36KHZ Q3 BC337 R22 10k To enhance viewing, please print to A36 RadioFans.CN Cambridge Audio Azur 640C V2 CD Player AP175164 Front Panel PCB Layout (Top Side) To enhance viewing, please print to A37 RadioFans.CN Cambridge Audio Azur 640C V2 CD Pla

17、yer AP175164 Front Panel PCB Layout (Bottom Side) To enhance viewing, please print to A38 RadioFans.CN AP17519/2 AP PART NO VALUEDESCRIPTIONQTY COMPONENT IDENT FACTORY PART NONOTES RESISTORS 82R0.25W 1% Metal Film Resistor1R201011-002014-000 100R0.25W 1% Metal Film Resistor2R151011-001014-000 220R0.

18、25W 1% Metal Film Resistor2R1, 141012-201014-000 1K50.25W 1% Metal Film Resistor1R81011-502014-000 2K20.25W 1% Metal Film Resistor1R18 2K70.25W 1% Metal Film Resistor1R51012-702014-000 3K30.25W 1% Metal Film Resistor1R111013-302014-000 4K70.25W 1% Metal Film Resistor3R12, 16, 191014-702014-000 5K60.

19、25W 1% Metal Film Resistor2R2, 17 10K0.25W 1% Metal Film Resistor3R6, 13, 221011-003014-000 27K0.25W 1% Metal Film Resistor1R31012-703014-000 33K0.25W 1% Metal Film Resistor1R41013-303014-000 68K0.25W 1% Metal Film Resistor1R101016-803014-000 82K0.25W 1% Metal Film Resistor2R7, 91018-203014-000 100R

20、 Multi turn pot1R21 1nFCeramic 50V 10% 5mm pitch 2C2, 31100-102043-000 100nCeramic 50V X7R 10% 5mm pitch 2C1, 4 10uF 25VRadial Electrolytic, 20%, 1C5, 61102-100024-000 PY214BC337-25NPN small signal transistor TO-923Q1, 3, 41300-337000-100 PY219BC327-25PNP small signal transistor TO-921Q21301-327000-

21、100 PY054TSOP1836SS3V IR Receiver module (VISHAY)1U23001-183600-001 PIC16C505Microchip 14 pin 8 Bit PIC1U34116-505054-200 Programmed with: AP18402/1 640CV2 V1.0.hex PD0121N5819Schottky diode1D1 PY064Blue LED3mm Blue flat top LED1D23100-000030-003 PY043Tact switchTACT SW 2P2T KPT-1105A (5MM)6SW1, 2,

22、3, 4, 5, 62400-020200-000 PY936AP17522/1 Positive LCD for V2 1LCD13110-066350E000 PY806LCD back light assembly16600-990095-000 Cambridge Azur 640C V2 Front Panel PCB Assembly BOM MISCELLANEOUS SEMICONDUCTORS TRANSISTORS CAPACITORS Note: resistors, capacitors and other generic electronic components a

23、re not usally stocked by the manufacturer. Please obtain these locally. 9 RadioFans.CN AP17519/3 AP Part No ValueDescriptionQtyComponent IdentFactory Part NoNotes 82R0.25W 1% Metal Film Resistor1R201011-002014-000 100R0.25W 1% Metal Film Resistor2R151011-001014-000 220R0.25W 1% Metal Film Resistor2R

24、1, 141012-201014-000 1K50.25W 1% Metal Film Resistor1R81011-502014-000 2K20.25W 1% Metal Film Resistor1R18 2K70.25W 1% Metal Film Resistor1R51012-702014-000 3K30.25W 1% Metal Film Resistor1R111013-302014-000 4K70.25W 1% Metal Film Resistor3R12, 16, 191014-702014-000 5K60.25W 1% Metal Film Resistor2R

25、2, 17 10K0.25W 1% Metal Film Resistor3R6, 13, 221011-003014-000 27K0.25W 1% Metal Film Resistor1R31012-703014-000 33K0.25W 1% Metal Film Resistor1R41013-303014-000 68K0.25W 1% Metal Film Resistor1R101016-803014-000 82K0.25W 1% Metal Film Resistor2R7, 91018-203014-000 200R BOCHEN 3296P side adjst MUL

26、TI turn pot 1R21*Revised 1nFCeramic 50V 10% 5mm pitch 2C2, 31100-102043-000 100nCeramic 50V X7R 10% 5mm pitch 2C1, 4 10uF 25VRadial Electrolytic, 20%, 1C5, 61102-100024-000 PY214BC337-25NPN small signal transistor TO-923Q1, 3, 41300-337000-100 PY219BC327-25PNP small signal transistor TO-921Q21301-32

27、7000-100 PY054 TSOP1836SS 3V IR Receiver module (VISHAY)1U23001-183600-001 PIC16C505Microchip 14 pin 8 Bit PIC1U34116-505054-200 Programmed with: AP18402/1 640CV2 V1.0.hex PD0121N5819Schottky diode1D1 PY064Blue LED3mm Blue flat top LED1D23100-000030-003 PY043Tact switchTACT SW 2P2T KPT-1105A (5MM)6S

28、W1, 2, 3, 4, 5, 62400-020200-000 PY936AP17522/1 Positive LCD for V2 1LCD1RCL IS06635P00V0 AP13344/*LCD holder1 PY806LCD back light assembly1 Semiconductors Miscellaneous * PLEASE NOTE: All components that appear in Red or Bold are additional items to this Bom AP17519/3 and will not appear on AP17519

29、/2. Cambridge Azur 540C/640C V2 Front Panel PCB Assembly BOM - Revised Resistors Capacitors Transistors Note: resistors, capacitors and other genericelectronic components are not usually stocked by the manufacturer. Please obtain these locally. 10 RadioFans.CN Cambridge Audio Azur 640C V2 CD Player

30、AP184321 Servo PCB Schematic SEG14 77 SEG15 76 SEG16 75 SEG17 74 SEG18 73 NC 72 NC 71 NC 70 NC 69 NC 68 NC 67 NC 66 NC 65 NC 64 NC 63 NC 62 NC 61 NC 60 NC 59 NC 58 NC 57 NC 56 NC 55 NC 54 NC 53 FL/TL 52 VDD 51 SEG13 78 SEG12 79 SEG11 80 SEG10 81 SEG9 82 SEG8 83 SEG7 84 SEG6 85 SEG5 86 SEG4 87 SEG3 8

31、8 SEG2 89 SEG1 90 SEG0 91 COM3 92 COM2 93 COM1 94 COM0 95 VLC 96 NC 97 NC 98 NC 99 VDD 100 VSS 50 (BOOT) 49 VAREF 48 AD K1 47 AD K2 46 AD K3 45 PWR DET 44 NC 43 NC 42 OLT 41 CLT 40 SLT 39 D-OPEN 38 D-CLOSE 37 BUS3 36 BUS2 35 BUS1 34 BUS0 33 BUCK 32 CEE 31 VSSS 1 XOUT 2 XIN 3 RESET 4 NC 5 NC 6 TEST 7

32、 NC 8 REMOTE 9 MUTE 10 NC 11 NC 12 NC 13 SCK2 14 (SI2) 15 (SO2) 16 (WAIT) 17 NC 18 NC 19 NC 20 NC 21 NC 22 NC 23 NC 24 NC 25 NC 26 NC 27 NC 28 CORW 29 RES 30 U3 TOSHCDMCU 1 2 3 4 5 6 7 CN6 LCD 1 2 3 4 5 6 7 8 CN5 LCD 1 2 3 4 5 6 7 8 CN4 LCD R22 NC R21 1K +5V C83 470uF 16V C85 100uF 16V +5V +5VDD C84

33、 220uF 16V Q13 9014C X2 CRYSTAL 7.3728MHz C81 25pF C80 25pF C79 100nF R19 3K3 R18 10K D9 1N4148 R20 1K 1 2 3 4 5 6 7 8 CN3 PROGRAMMING R65 10K R662K2 R1710K +5V R27 10K +5V +5VDD XVSS 77 VDD4 76 PXO 75 PXI 74 VSS4 73 TESIO1 72 TESIN 71 DACT 70 CKSE 69 DMOUT 68 IO3 67 IO2 66 IO1 65 IO0 64 VSS3 63 VDD

34、3 62 FLGD 61 FLGC 60 FLGB 59 FLGA 58 SEL 57 2VREF 56 DMO 55 TEBC2 54 TEBC1 53 TEBC0 52 RFGC 51 XI 78 XO 79 XVDD 80 DVSR 81 RO 82 DVDD 83 DVR 84 LO 85 DVSL 86 TEST1 87 TEST2 88 TEST3 89 BUS0 90 BUS1 91 BUS2 92 BUS3 93 VDD 94 VSS 95 BUCK 96 CCE 97 TEST4 98 TSMOD 99 RST 100 VREF 50 TRO 49 FOO 48 TEZI 4

35、7 TEI 46 TSIN 45 SBAD 44 FEI 43 RFRP 42 RFZI 41 RFCT 40 AVDD1 39 RFI 38 SLCO 37 AVSS1 36 VCOF 35 VCOREF 34 PVREF 33 LPFO 32 LPFN 31 TEST0 1 HSO 2 UHSO 3 EMPH 4 LRCK 5 VSS1 6 BCK 7 AOUT 8 DOUT 9 MBOV 10 IPF 11 SBOK 12 CLCK 13 VDD1 14 VSS2 15 DATA 16 SFSY 17 SBSY 18 SPCK 18 SPDA 20 COFS 21 MONIT 22 VD

36、D2 23 TESIO0 24 P2VREF 25 HSSW 26 ZDET 27 PDO 28 TMAXS 29 TMAX 30 U2 TC9462F VCC 1 RFGC 2 GMAD 3 FNI 4 FPI 5 TNI 7 MDI 8 LDO 9 SEL 10 TEB 11 2VRO 12 TEN 13 TEO 14 SBAD 15 FEO 16 FEN 17 SEB 18 VRO 19 RFRP 20 BTC 21 RFCT 22 PKC 23 RFRPIN 24 RFGO 25 GVSW 26 AGCIN 27 RFO 28 GND 29 RFN2 30 TPI 6 U1 TA215

37、3FN PW GND 1 OUT(-)1 2 PVCC1 3 OUT(+)1 4 VIN1 5 VRI 6 VCI 7 VIN2 8 OUT(+)2 9 PVCC2 10 OUT(-)2 11 PW GND 12 PW GND 13 OUT(-)3 14 PVCC3 15 OUT(+)3 16 VIN3 17 S GND 18 S VCC 19 VIN4 20 OUT(+)4 21 PVCC4 22 OUT(-)4 23 PW GND 24 U6 TA2092N R1510K R39 10K R1410K R1310K R1210K +5V R1110K R6 220K R768K R515K

38、 R947K C8 0.015uF C76 47pF C7447uF 16V R810K C750.01uF C60.0027uF 1 2 3 CN1 DIGITAL OUT +5V R1047R C11 0.047uF C10 47uF 16V C9 47uF 16V 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 CN16 MECH 1 2 3 4 5 6 CN15 MOTOR DRIVE +8V C56 220uF 16V C59100nF R64 10K +5V C58 100nF C57 100nF R42 3K3 C270.047uF C260.047

39、uF R41 3K3 C60 0.047uF C61 100nF C1422uF 16V C2847uF 16V C312200pF no stuff C302200pF no stuff R3810K no stuff R3710K no stuff R4010R 1/4W NC NC NC NC NC R36 100K no stuff R35 100K no stuff X1 CRYSTAL 16.9344MHz C1715pF C1615pF C15 0.047uF NC C19 0.047uF C1847uF 16V NC NC NC NC NC NC NC NC NC NC NC

40、NC R43 10K R45 3K3 C24470pF C25470pF R44 3K3 C62 100nF R60 1K R59 68K L1 47uH C66 0.047uF C65 220uF 16V C20 47uF 16V C67 100nF C64100nF C68 22uF R58 0R R5610K R5510K R5410K R5310K R52 56K R51 47K R50 47K R49 47K R48 47K R57 56K L2 10uH Q1 9015 R62 15R C69100uF 16V R463K3 R473K3 C23 0.047uF C220.047u

41、F R63 100K R1 2K2 C1 3pF R3 1K C73 100pF R2 10K R4220R C2100nF C720.22uF C30.22uF C4100nF R61 27K C71100nF C7 0.01uF C5 0.047uF C77 47uF 16V C78 47uF 16V C70 47uF 16V NC D8 1N4148 NC NC NC NC NC NC NC NC NC NC NC NC NC NC C130.047uF C121uF 16V C2947uF 16V R16 10K 1 2 3 4 5 CN8 DRAW DRIVE R31 10K R30

42、 10K +5V Q12 8050 Q7 8050 Q9 8550 Q10 8550 R33 470R R34 470R R67 27R 1W +8V R28 10K R29 10K +5V+5V NC NC NC NC NC NC NC NC NC NC NC NC NC NC NC NC NC NC NC NC NC NC NC NC NC NC NC NC C86 100nF L3 100uH R2610K R251K R2310K R2410K R32 4K7 REMOTE REMOTE LK1 LINK OPEN = F/L SHORT = T/L +5VCC NC NC NC NC

43、 NC NC NC NC NC NC NC NC NC NC 1 2 3 4 5 CN12 AUDIO OUT no stuff 1 2 3 4 5 CN2 DATA OUT EMPH BCK PCMD LRCK GND 1 2 CN17 XTALI OSC GND SET LCD CONTRAST +5V RESET BOOT GND WAIT SCK2 SI2 SO2 REMOTE +5V GND K1 K2 C21 0.0047uF OLT GND CLT OPEN CLOSE GND ROUT LOUT MUTE1 MUTE +5V GND D-OUT FC- TR- TR+ FC+

44、PD VR LD GND F C B A D E VCC VC SLT- SLT+ FM+ FM- DM- DM+ SEG18 SEG17 SEG16 SEG15 SEG14 SEG13 SEG12 SEG11 SEG10 SEG9 SEG8 SEG7 SEG6 SEG5 SEG4 SEG3 SEG2 SEG1 SEG0 COM0 COM1 COM2 COM3 L4100uH L5 100uH C82 10uF 16V 1 2 CN18 XTALO GND C87 1nF 1 2 CN20 MUTE 1 2 3 4 5 6 7 CN7 CONTROL KEYS D10 1N4148 D11 1

45、N4148 R76 4K7 Q8 8050Q11 8050 PWR DET RESET R? 100R FU1 T2AL VI 1 VO 3 GND 2 U8 7805 C45 100nF C44 100nF C? 470uF 16V +5V 1 2 CN19 AC IN D5 IN4004 D4IN4004 D2 IN4004D3IN4004 C49 100nF C50 3300uF 25V C54 100nF VI 1 VO 3 GND 2 U7 7808 C48 100nF C53 100nF C51 100nF C52 100nF C47 470uF 16V +8V 14.5V AC

46、1 2 CN21 FP DIS To enhance viewing, please print to A311 RadioFans.CN Cambridge Audio Azur 640C V2 CD Player AP129277 Servo PCB Layout (Top Side) To enhance viewing, please print to A312 RadioFans.CN Cambridge Audio Azur 640C V2 CD Player AP129277 Servo PCB Layout (Bottom Side) To enhance viewing, p

47、lease print to A313 RadioFans.CN AP18434/1 AP PART NO VALUEDESCRIPTIONQTYCOMPONENT IDENTFACTORY PART NONOTES 10R0.25 W Metal Film Resistor1R401011-000014-000 15R0.125 W Metal Film Resistor1R62 27R1 W Carbon Resistor1R671002-700310-000mount off PCB by 5mm 47R0.125 W Metal Film Resistor1R10,1014-70001

48、8-000 100R0.125 W Metal Film Resistor1wirelink1011-001016-000 wirelink is positioned between C68 and L2. This must be 100R resistor 220R0.125 W Metal Film Resistor1R41012-201018-000 470R0.125 W Metal Film Resistor2R33, 341014-701016-000 1K0.125 W Metal Film Resistor5R3, 20, 21, 25, 601011-002018-000

49、 2K20.125 W Metal Film Resistor2R1, 66 1012-202016-000 3K30.125 W Metal Film Resistor7R19, 41, 42, 44, 45, 46, 471013-302018-000 4K70.125 W Metal Film Resistor2R32, 761014-702016-000 10K0.125 W Metal Film Resistor26 R2, 8, 11, 12, 13, 14, 15, 16, 17, 18, 23, 24, 26, 27, 28, 29, 30, 31, 39, 43, 53, 54, 55, 56, 64, 65 1011-003016-000 15K0.125 W Metal Film Resist