《HarmanKardon-AVR630-avr-sm维修电路图 手册.pdf》由会员分享，可在线阅读，更多相关《HarmanKardon-AVR630-avr-sm维修电路图 手册.pdf（126页珍藏版）》请在收音机爱好者资料库上搜索。
1、 harman/kardon AVR430 AVR430 7 X 65W 7.1 CHANNEL A/V RECEIVER AVR630 AVR630 7 X 75W 7.1 CHANNEL A/V RECEIVER SERVICE MANUAL CONTENTS ESD WARNING.2 LEAKAGE TESTING.3 AVR430 BASIC SPECIFICATIONS.4 AVR630 BASIC SPECIFICATIONS.5 FRONT PANEL CONTROLS.6 REAR PANEL CONNECTIONS.9 REMOTE CONTROL FUNCTIONS.12
2、 TROUBLESHOOTING GUIDE.16 PROCESSOR RESET16 SERVICE PROCEDURE.17 BULLETIN HK2004-04.20 TECH TIP HKTT2004-03.23 TECH TIP HKTT2003-01.27 BLOCK DIAGRAM.28 EXPLODED VIEW.29 EXPLODED VIEW PARTS LIST.30 AVR630 MECHANICAL PARTS LIST.32 AVR630 ELECTRICAL PARTS LIST.34 AVR430 MECHANICAL PARTS LIST.54 AVR430
3、ELECTRICAL PARTS LIST.56 SEMICONDUCTOR PINOUTS.75 PCB DRAWINGS.103 SCHEMATICS.114 WIRING DIAGRAM.125 PACKING.126 harman/kardon, Inc. 250 Crossways Park Dr. Woodbury, New York 11797 Rev2 10/2005 www.freeservicemanuals.infoIts Free www.freeservicemanuals.info RadioFans.CN Eachprecautioninthismanualsho
4、uldbefollowedduringservicing. Components identified with the IEC symbolin the parts list are special significance to safety. When replacing a component identified with , use only the replacement parts designated, or parts with the same ratings or resistance, wattage, or voltage that are designated i
5、n the parts list in this manual. Leakage-current or resistance measurements must be made to determine that exposed parts are acceptably insulated from the supply circuit before retuming the product to the customer. Some semiconductor (solid state) devices can be damaged easily by static electricity.
6、 Such components commonly are called Electrostatically Sensitive (ES) Devices. Examples of typical ES devices are integrated circuits and some field effect transistors and semiconductor chip components. The following techniques should be used to help reduce the incidence of component damage caused b
7、y static electricity. 1. Immediately before handling any semiconductor component or semiconductor-equipped assembly, drain off any electrostatic charge on your body by touching a known earth ground. Alternatively, obtain and wear a commercially available discharging wrist strap device, which should
8、be removed for potential shock reasons prior to applying power to the unit under test. 2. After removing an electrical assembly equipped with ES devices, place the assembly on a conductive surface such as aluminum foil, to prevent electrostatic charge build-up or exposure of the assembly. 3. Use onl
9、y a grounded-tip soldering iron to solder or unsolder ES devices. 4. Use only an anti-static solder removal device. Some solder removal devices not classified as anti-static can generate electrical charges sufficient to damage ES devices. 5. Do not use freon-propelled chemicals. These can generate e
10、lectrical change sufficient to damage ES devices. 6. Do not remove a replacement ES device from its protective package until immediately before you are ready to install it. (Most replacement ES devices are packaged with leads electrically shorted together by conductive foam, aluminum foil or compara
11、ble conductive material.) 7. Immediately before removing the protective material from the leads of a replacement ES device, touch the protective material to the chassis or circuit assembly into which the device will be installed. Be sure no power is applied to the chassis or circuit, and observe all
12、 other safety precautions. 8. Minimize bodily motions when handling unpackaged replacement ES devices. (Otherwise harmless motion such as the brushing together or your clothes fabric or the lifting of your foot from a carpeted floor can generate static electricity sufficient to damage an ES devices.
13、 CAUTION : AVR430/AVR630AVR430/AVR630 harman/kardon www.freeservicemanuals.infoIts Free www.freeservicemanuals.info RadioFans.CN 2 1. Inspect all lead dress to make certain that leads are not pinched or that hardware is not lodged between the chassis and other metal partsintheunit. 2. Be sure that a
14、ny protective devices such as nonmetallic control knobs, insulating fish- papers,cabinetbacks,adjustmentand compartment covers or shields, isolation resistor-capacitynetworks,mechanical insulators, etc. Which were removed for the servicingareproperlyre-installed. Before returning the unit to the use
15、r, perform the following safety checks : 3. Be sure that no shock hazard exists ; check for leakage currentusingSimpsonModel229LeakageTester,standard equipment item No. 21641, RCA Model WT540A or use alternate method asfollows : Plug the power cord directly Into a 120 volt AC receptacle (do not use
16、an Isolation Transformer for this test). Using two clip leads, connect a 1500ohms,10wattResistorparalleledbya0.15uFcapacitor,inserieswithallexposedmetalcabinetpartsandaknownearthground,such as a water pipe or conduit. Use a VTVM or VOM with 1000 ohms per volt, or higher sensitivity to measure the AC
17、 voltage drop across the resistor. (See diagram) Move the resistor connection to each exposed metal part having a return path to the chassis (antenna, metal, cabinet,screwheads,knobsandcontrolshafts,escutcheon,etc.)andmeasuretheACvoltagedropacrosstheresistor.(Thistestshouldbe performedwiththe0.35vol
18、tRMSormoreisexcessiveandindicatesapotentialshockhazardwhichmustbecorrectedbeforereturningthe unittotheowner. AVR430/AVR630AVR430/AVR630 harman/kardon www.freeservicemanuals.infoIts Free www.freeservicemanuals.info RadioFans.CN 3 AVR 430 TECHNICAL SPECIFICATIONS Audio Section Stereo Mode Continuous A
19、verage Power (FTC) 80 Watts per channel, 20Hz20kHz, 0.07% THD, both channels driven into 8 ohms Seven-Channel Surround Modes Power per Individual Channel Front L&R channels: 65 Watts per channel 0.07% THD, 20Hz20kHz into 8 ohms Center channel: 65 Watts 0.07% THD, 20Hz20kHz into 8 ohms Surround (L &
20、R Side, L & R back) channels: 65 Watts per channel 0.07% THD, 20Hz20kHz into 8 ohms Input Sensitivity/Impedance Linear (High-Level)200mV/47k ohms Signal-to-Noise Ratio (IHF-A)95dB Surround System Adjacent Channel Separation Pro Logic I/II 40dB Dolby Digital (AC-3)55dB DTS55dB Frequency Response 1W (
21、+0dB, 3dB)10Hz 130kHz High Instantaneous Current Capability (HCC)40 Amps Transient Intermodulation Distortion (TIM)Unmeasurable Slew Rate40V/sec FM Tuner Section Frequency Range87.5108.0MHz Usable SensitivityIHF 1.3V/13.2dBf Signal-to-Noise RatioMono/Stereo 70/68dB DistortionMono/Stereo 0.2/0.3% Ste
22、reo Separation40dB 1kHz Selectivity400kHz, 70dB Image Rejection80dB IF Rejection90dB AM Tuner Section Frequency Range5201720kHz Signal-to-Noise Ratio45dB Usable SensitivityLoop 500V Distortion1kHz, 50% Mod 0.8% Selectivity10kHz, 30dB Video Section Television FormatNTSC Input Level/Impedance1Vp-p/75
23、ohms Output Level/Impedance1Vp-p/75 ohms Video Frequency Response (Composite and S-Video)10Hz8MHz (3dB) Video Frequency Response (Component Video) 10Hz50MHz (3dB) General Power RequirementAC 120V/60Hz Power Consumption59W idle, 940W at rated power output (7 channels driven) DimensionsProductShipping
24、 Width17.3 inches (440mm)20.1 inches (510mm) Height6.5 inches (165mm)10 inches (254mm) Depth17.1 inches (435mm)22.2 inches (565mm) Weight39 lb (17.7kg)45 lb (20.4kg) Depth measurement includes knobs, buttons and terminal connections. Height measurement includes feet and chassis. All features and spe
25、cifications are subject to change without notice. Harman Kardon, Power for the Digital Revolution and Logic 7 are registered trademarks of Harman International Industries, Incorporated. is a trademark of Harman International Industries, Incorporated (patent no. 5,386,478). *Manufactured under licens
26、e from Dolby Laboratories.“Dolby,”“Pro Logic” and the Double-D symbol are trademarks of Dolby Laboratories. DTS, DTS Surround, DTS-ES and DTS Neo:6 are registered trademarks of Digital Theater Systems, Inc. VMAx is a registered trademark of Harman International Industries, Incorporated, and is an im
27、plementation of Cooper Bauck Transaural Stereo under patent license. A-BUS and A-BUS/Ready are registered trademarks of Leisure Tech Electronics Pty Ltd.Australia. TiVo is a registered trademark of TiVo, Inc. Replay TV is a registered trademark of SONICblue, Inc. TM TECHNICAL SPECIFICATIONS 51 AVR43
28、0/AVR630AVR430/AVR630 harman/kardon www.freeservicemanuals.infoIts Free www.freeservicemanuals.info RadioFans.CN AVR 630 TECHNICAL SPECIFICATIONS Audio Section Stereo Mode Continuous Average Power (FTC) 90 Watts per channel, 20Hz20kHz, 0.07% THD, both channels driven into 8 ohms Seven-Channel Surrou
29、nd Modes Power per Individual Channel Front L&R channels: 75 Watts per channel 0.07% THD, 20Hz20kHz into 8 ohms Center channel: 75 Watts 0.07% THD, 20Hz20kHz into 8 ohms Surround (L & R Side, L & R back) channels: 75 Watts per channel ?SELECT?UP(FOR?2?SEC)?-?SELECT?NTSC/PAL?BY?TOGGLE?SELECT?UP?KEY -
30、?SET?NTSC?OR?PAL?BY?SET?KEY ?micom Vref Key_in1 Key_in2 (77) (78) S200 S201 S20 S203 S204 S205 S206 S207 S208 S211 S212 S213 S214 S215 S216 S217 S218 S219 S209S220 Standby?on/off Surr.?Mode Surr.?Down?Select?Up Surr.?Up?Select?Down Tunning?Down Tunning?Up AM/FM(BAND) Preset?Down Preset?Up Source?Dow
31、n Tune.?Mode Source?Up Test?Tone Select?Up(change?adjustment) Speaker?Adjustment Channel?Adjustment Digital?Select Delay?Adjustment Select?Down(change ) Select(SET?adjustment) 120 AVR430/AVR630AVR430/AVR630 harman/kardon www.freeservicemanuals.infoIts Free www.freeservicemanuals.info RadioFans.CN uP
32、D70F3033B?(V850/SB1) PORT?ASSIGNMENT AVR540/340 PORT?ASSIGNMENT PINDESCRIPTIONRECEVIER?NAMEIN/OUTFUNCTION 1P14/SO1/TXD0RS-232?TXTXCPU?FLASH?UPGRADE?UART?TX?PORT 2P15/SCK1/ASCK0VPP_CONTROLOUTFlash?Upgrade?VPP?Control?Pin 3P20/SI2/SDA1HDCD?GAINOUTHDCD?GAIN?(DSP) 4P21/SO2THX?GAINOUTTHX?GAIN?(DSP) 5P22/
33、SCK2/SCL1FIP?RST?/?FL?STBOUTFIP?DRIVER?IC?RESET?/?FL?STROBE 6P23/RXD1/SI3FIP?SI?/?FL?BLKSIFIP?DRIVER?IC?DATA?IN?/?FL?BLANK 7P24/TXD1/SO3FIP?SO?/?FL?DISOFIP?DRIVER?IC?DATA?OUT?/?FL?DI 8P25/ASCK1/SCK3FIP?CLK?/?FL?CLKSCKFIP?DRIVER?IC?CLOCK?OUT?(NEC?CPU?MASTER)?/?FL?CLK 9EVDDEVDDVDDVDD 10EVSSEVSSVDDGND
34、11P26/TI2/TO2ADC?RESETOUTADC?RESET(DSP) 12P27/TI3/TO3CODEC_RESETOUTCODEC?RESET(DSP) 13P30/TI00RMC_INCAPTUREREMOCON?IN 14P31/TI01CODEC_CEOUTCODEC?CHIP?ENABLE(DSP) 15P32/T110/S14RMC_MULTICAPTUREMULTI?ROOM?REMOCON 16P33/TI11/SO4CODEC?CLKOUTCODEC?CLK(DSP) 17P34/TO0/SCK4CODEC_DATA_OUTOUTCODEC?DATA_OUT(DS
35、P) 18P35/TO1CODEC_DATA_ININCODEC?DSP_IN(DSP) 19P36/TI4/TO4CODEC_INTINCODEC?INT(DSP) 20P37/TI5/TO5FAN?OUTOUTFAN?OUT?CONTROL(PWM) 21IC/VPPVPPIN?47K?Pull_Down,?FLASH?WRITE?7.8V 22P100/RTP0/KR0DSP_RESETOUTCS49400?RESET(DSP) 23P101/RTP1/KR1DSP_HINBSYINCS49400?HINBSY(DSP) 24P102/RTP2/KR2DSP_INTERQ_ABINCS4
36、9400?INTERQ_AB(DSP) 25P103/RTP3/KR3DSP_CLK_ABOUTCS49400?CLK?AB 26P104/RTP4/KR4DSP_CE_ABOUTCS49400?CE?AB 27P105/RTP5/KR5DSP_DATA_OUT_ABOUTCS49400?DATA?OUT(DSP) 28P106/RTP6/KR6DSP_DATA_IN_ABIN/OUTCS49400?DATA?IN(DSP) 29P107/RTP7/KR7DSP_INTERQ_CINCS49400?INTERQ?C(DSP) 30P110/WAITDSP_CLK_COUTCS49400?CLK
37、?C(DSP) 31P111DSP_CE_COUTCS49400?CE?C(DSP) 32P112DSP_DATA_OUT_COUTCS49400?DATA?OUT?C(DSP) 33P113 DSP_DATA_IN_C IN/OUTCS49400?DATA?IN?C(DSP) 34/RESETRESETINLOW?ACTIVE 35XT1XT1INPull_Down 36XT2XT2OUTOPEN 37REGCREGCVDDVDD 38X2Fx_OUTOUT20.00MHz?RESONATOR? 39X1Fx_ININ20.00MHz?RESONATOR? 40VSSVSSVDDGND 41
38、VDDVDDVDD5V? 42CLKOUTCLKOUTOUTOPEN?(STOP?MODE:?LOW) 43P90/LBEN/WRL ADC?MODE?0 OUTADC?MODE?0(DSP) 44P91/UBEN ADC?MODE?1 OUTADC?MODE?1(DSP) 45P92/RW/WRHHP?MUTEOUTHEADPHONE?MUTE 46P93/DSTB/RDEEPROM?DATAOUTEEPROM?DATA 47P94/ASTBEEPROM?CLKOUTEEPROM?CLK 48P95/HLDAK VOL?IC?CE OUTTC9481/TC9482/TC9459?CE 49P
39、96/HLDRQ4094?CEOUT4094?CHIP?ENABLE AVR430/AVR630AVR430/AVR630 harman/kardon www.freeservicemanuals.infoIts Free www.freeservicemanuals.info RadioFans.CN uPD70F3033B?(V850/SB1) PORT?ASSIGNMENT AVR540/340 50P404094?CLKOUT4094?CLK PINDESCRIPTIONRECEVIER?NAMEIN/OUTFUNCTION 51P414094?DATAOUT4094?DATA? 52
40、P429482/59/81?DATAOUT9482/59/81?VOL?IC?DATA 53P439482/59/81?CLKOUT9482/59/81?VOL?IC?CLK 54P44A?DATAOUT9273_1,?9273_3,?9162,?9162_2,?9163?DATA 55P45A?CLKOUT9273_1,?9273_3,?9162,?9162_2,?9163?CLK 56P469273?CE1OUT9273_1,?9162,?9163?CHIP?ENABLE 57P479273_CE3OUT9273_3,?9162_2?CHIP?ENABLE 58BVDDBVDDVDDVDD
41、 59BVSSBVSSVDDGND 60P50T_MUTEOUTTUNER?MUTE?OUT 61P51TUNEDINTUNED?CHECK?IN 62P52T_CEOUTTUNER?PLL?IC(LC72131)?CHIP?ENABLE 63P53T_CLOCKOUTTUNER?PLL?IC(LC72131)?CLOCK 64P54T_DATA?IN/STEREOINTUNER?PLL?IC(LC72131)?DATA?IN?/?STEREO?CHECK 65P55T_DATA?OUTOUTTUNER?PLL?IC(LC72131)?DATA?OUT 66P56MMUTEOUTFRONT?S
42、PEAKER?MUTE 67P57CMUTEOUTCENTER?SPEAKER?MUTE 68P60SMUTEOUTSURROUND?SPAKER?MUTE 69P61SBMUTEOUTSURR?BACK?SPEAKER?MUTE 70P62SUBMUTEOUTSUB?WOOFER?MUTE 71P63PMUTEOUTPOWER?MUTE 72P64RECMUTEOUTREC?MUTE 73P65MULTI?MUTEOUTMULTI?ROOM?MUTE 74AVDDAVDDVDDVDD 75AVSSAVSSVDDGND 76AVREFAVREFVDDVDD(AD?KEY?PULL?UP?VDD
43、) 77P70/ANI0AD?KEY1ADINA/D?KEY?INPUT1 78P71/ANI1AD?KEY2ADINA/D?KEY?INPUT2 79P72/ANI2FAN?IN1ADINTEMPERATURE?SENSOR?INPUT 80P73/ANI3FAN?IN2ADINLEVEL?SENSOR?INPUT 81P74/ANI4ENCODE1INVOLUME?ENCODER?INPUT?1 82P75/ANI5ENCODE2INVOLUME?ENCODER?INPUT?2 83P76/ANI6yc/comp?checkADINY/C,COMPO?jack?check?in? 84P7
44、7/ANI7HP_ININHEADPHONE?INPUT 85P80/ANI8STEPINTUNER?FREQ?OPTION 86P81/ANI9NTSC/PAL?SELINNC 87P82/ANI10PROTECTIONINPROTECTION?IN 88P83/ANI11MODELINNC 89P00/NMISTANDBYOUTMAIN?POWER?ON/OFF 90P01/INTP0POWER?DOWNINTP0POWER?DOWN?CHECK?&?WAKE?UP?:?RISING?EDGE 91P02/INTP1RDS_CLOCKINTP1RDS_CLOCK?(INTERRUPT)?:
45、?FALLING?EDGE 92P03/INTP2RDS_DATAINRDS_DATA 93P04/INTP3COAX_INOUT?SELOUTCOAX?IN/OUT?SELECT 94P05/INTP4/ADTRGSYNC?pluse?checkINSYNC?PLUSE?CHECK(OSD?IC?7PIN) 95P06/INTP5/RTPTRGSYNC?CHECK IN SYNC?CHECK(OSD?IC?29PIN) 96P07/INTP6A19OUTA19 97P10/SI0OSD?CEOUTOSD?CHIP?ENABLE 98P11/SO0OSD?CLKOUTOSD?CLK 99P12
46、/SCK0OSD?DATAOUTOSD?DATA 100P13/SI1/RXD0RS-232?RXRXCPU?FLASH?UPGRADE?UART?RX?PORT AVR430/AVR630AVR430/AVR630 harman/kardon www.freeservicemanuals.infoIts Free www.freeservicemanuals.info RadioFans.CN DSP BOARD (TOP VIEW) AVR430/AVR630AVR430/AVR630 harman/kardon www.freeservicemanuals.infoIts Free ww
47、w.freeservicemanuals.info RadioFans.CN DSP BOARD (BOTTOM VIEW) AVR430/AVR630AVR430/AVR630 harman/kardon www.freeservicemanuals.infoIts Free www.freeservicemanuals.info RadioFans.CN PROCESSOR BOARD (TOP VIEW) AVR430/AVR630AVR430/AVR630 harman/kardon www.freeservicemanuals.infoIts Free www.freeservice
48、manuals.info RadioFans.CN PROCESSOR BOARD (BOTTOM VIEW) AVR430/AVR630AVR430/AVR630 harman/kardon www.freeservicemanuals.infoIts Free www.freeservicemanuals.info RadioFans.CN MAIN AMP BOARD AVR430/AVR630AVR430/AVR630 harman/kardon 107 www.freeservicemanuals.infoIts Free www.freeservicemanuals.info RadioFans.CN FRONT BOARD (BOTTOM VIEW) AVR430/AVR630AVR430/AVR630 harman/kardon www.freeservicemanuals.infoIts Free www.freeservicemanuals.info RadioFans.CN FRONT BOARD (TOP VIEW) AVR430/AVR630AVR430/AVR630 harman/kardon www.freeservicemanuals.infoIts Fr
免费区 
