HarmanKardon-HKTS15-htss-sm维修电路原理图.pdf

《HarmanKardon-HKTS15-htss-sm维修电路原理图.pdf》由会员分享，可在线阅读，更多相关《HarmanKardon-HKTS15-htss-sm维修电路原理图.pdf（31页珍藏版）》请在收音机爱好者资料库上搜索。

1、harman/kardon SUB-TS15SUB-TS15 (HKTS 15 SUBWOOFER) SERVICE MANUAL harman/kardon, Inc. 250 Crossways Park Dr. Woodbury, New York 11797 Rev0 2/2007 RadioFans.CN CONTENTS BASIC SPECIFICATIONS . . . . . . . . . . . . . . . . 1 DETAILED SPECIFICATIONS. . . . . . . . . . . . . . . . . . . . . . . 2 PACKAG

2、ING. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 CONTROLS Filter OFF Level MIN (Full CCW) Phase, Auto/On switches do not matter General Unit Function (UUT = Unit Under Test) 1) From the signal generator, connect one line level (RCA) cable to the Subwoofer Line Level Input jacks

3、 L/R on the UUT. Use a Y-cable from a mono source if necessary to connect to both inputs. Do not connect to the single, purple SUB input. 2) Turn on generator; adjust to 75mV, 50 Hz. 3) Plug in UUT; turn the power switch ON. Turn LEVEL control full clockwise (MAX) 4) LED should turn from Amber to Bl

4、ue (on top of UUT); immediate and vigorous bass response should be heard and felt from port tube opening. 5) Turn off generator, turn LEVEL control full counterclockwise (MIN), and disconnect RCA cable. 6) Connect one pair of speaker cables to Speaker Level input terminal (IN) on UUT. Cables should

5、be connected to an integrated amplifier fed by the signal generator. 7) Turn on generator and adjust so that speaker level input at the amplifier is 1.6V, 50 Hz. Turn LEVEL control full clockwise. 8) LED should turn from Amber to Blue; immediate and vigorous bass response should be heard and felt fr

6、om the port tube opening. Sweep Function 1) Follow steps 6-8 above, using a sweep generator as a signal source. 2) Sweep generator from 20Hz to 300Hz. Listen to the cabinet and drivers for any rattles, clicks, buzzes or any other noises. If any unusual noises are heard, remove woofers and test. Driv

7、er Function 1) Remove woofer from cabinet; detach + and - wire clips. 2) Check DC resistance of woofer; it should be 3.0 ohms 10% 3) Connect a pair of speaker cables to driver terminals. Cables should be connected to an integrated amplifier fed by a signal generator. Turn on generator and adjust so

8、that speaker level output is 5.0V. 4) Sweep generator from 20Hz to 1kHz. Listen to driver for any rubbing, buzzing, or other unusual noises. SUB-TS15SUB-TS15 harman/kardonharman/kardon 11 SUB-TS15SUB-TS15 harman/kardonharman/kardon 12 SUB-TS15SUB-TS15 harman/kardonharman/kardon 13 SUB-TS15SUB-TS15 h

9、arman/kardonharman/kardon 14 SUB-TS15SUB-TS15 harman/kardonharman/kardon 15 SUB-TS15 (UL) AMP Troubleshooting Flow Chart no yes yes yes no yes yes LED red LED light green yes yes no yes yes no no yes yes yes no no yes yes yes no yes yes AMP no signal out DC voltage check Vcc Check+/-15VDC LED light

10、green or red Check Fuse,Transformer, D110, etc Check RY101,D102,Q113,Q114 etc Check Q107,Q108,Q105, Q106,Q103,Q104,U101,etc Check ,+VCC& -VCC DC voltage Check U101,Q115,Q116,R138 etc Check Q117,118,119,D109 etc Check,Q206,Q207,U203 etc Check U202 pin14 signal Check U201 pin14 signal Test R121,R122 s

11、ignal Check P102 signal The Amp Assy OK, END CheckU201,U202,VR201 VR202. etc Check J123,J124 etc Check limiter board C304 Check U301,R343,R344 , C340,Q301,Q302, etc Set R138 to R140S Voltage is 0.51VDC SUB-TS15SUB-TS15 harman/kardonharman/kardon 16 SUB-TS15SUB-TS15 harman/kardonharman/kardon 17 SUB-

12、TS15SUB-TS15 harman/kardonharman/kardon 18 SUB-TS15SUB-TS15 harman/kardonharman/kardon 19 SUB-TS15SUB-TS15 harman/kardonharman/kardon 20 SUB-TS15SUB-TS15 harman/kardonharman/kardon 21 SUB-TS15SUB-TS15 harman/kardonharman/kardon 22 SUB-TS15 120V Electrical parts list Part numberDescriptionQtyReferenc

13、e Designator MAIN/POWER PCB Resistors 110-10821jk2-eResistor 820 1W 5% jam crus and shaping 10mm (RoHS) 1R132 110-122r2j15-eResistor 2.2 1/2W 5% prone short crus 15mm (RoHS) 1R127 110-20331jk2-eResistor 330 2W 5% jam crus and shaping 5mm (RoHS) 2R146,R149 113-50r10j10-ecement Resistor 0.1 5W 5% stan

14、ding (RoHS) 2R121,R122 114-03302m0-esemi-fixed Resistor 3K 0.3W 20% (RoHS) 1R138 110-14472j26-eResistor 4.7K 1/4W 5% CF 26mm (RoHS) 2R147,R150 110-14681j26-eResistor 680 1/4W 5% CF 26mm (RoHS) 2R148,R151 110-16101j26-eResistor 100 1/6W 5% CF 26mm 1R120 110-16102j26-eResistor 1K 1/6W 5% CF 26mm (RoHS

15、) 1R124 110-16103j26-eResistor 10K 1/6W 5% CF 26mm (RoHS) 1R134 110-16105j26-eResistor 1M 1/6W 5% CF 26mm (RoHS) 1R143 110-16123j26-eResistor 12K 1/6W 5% CF 26mm (RoHS)2R135,R139 110-16152j26-eResistor 1.5K 1/6W 5% CF 26mm (RoHS) 6R103,R123,R136,R137,R141,R142 110-16153j26-eResistor 15K 1/6W 5% CF 2

16、6mm (RoHS) 4R118,R145,R152,R154 110-16154j26-eResistor 150K 1/6W 5% CF 26mm (RoHS)1R131 110-16181j26-eResistor 180 1/6W 5% CF 26mm (RoHS) 2R111,R114 110-16182j26-eResistor 1.8K 1/6W 5% CF 26mm (RoHS) 1R153 110-16223j26-eResistor 22K 1/6W 5% CF 26mm (RoHS) 3R128,R129,R133 110-16332j26-eResistor 3.3K

17、1/6W 5% CF 26mm (RoHS) 3R106,R107,R144 110-16392j26-eResistor 3.9K 1/6W 5% CF 26mm (RoHS) 2R105,R108 110-16393j26-eResistor 39K 1/6W 5% CF 26mm (RoHS) 1R126 110-16470j26-eResistor 47 1/6W 5% CF 26mm (RoHS) 4R112,R113,R115,R116 110-16471j26-eResistor 470 1/6W 5% CF 26mm (RoHS) 1R140 110-16472j26-eRes

18、istor 4.7K 1/6W 5% CF 26mm (RoHS) 3R110,R125,R130 110-16473j26-eResistor 47K 1/6W 5% CF 26mm (RoHS) 1R101 110-16560j26-eResistor 56 1/6W 5% CF 26mm (RoHS) 1R117 110-16563j26-eResistor 56K 1/6W 5% CF 26mm (RoHS) 1R104 110-16682j26-eResistor 6.8K 1/6W 5% CF 26mm (RoHS) 1R109 Capacitors 130-2b102k503-e

19、DISC Capacitor 1000P 50V 10% (RoHS) 1C116 130-3f104z503-eDISC Capacitor 0.1U 50V +80/-20% (RoHS) 4C108,C113,C115,C119 130-3f473m503-eDISC Capacitor 0.047U 50V 20% (RoHS) 1C106 130-sl101k503-eDISC Capacitor 100P 50V SL 10% (RoHS) 2C139,C140 132-104j503-eMYLAR Capacitor 0.1U 50V 5% (RoHS) 1C107 132-22

20、3ja03-eMYLAR Capacitor 0.022uF 100V 5% (RoHS) 4C124,C125,C126,C128 135-3105m50-eElectrolytic CAP. 1U 50V 20% (RoHS) 2C105,C112 135-3107m16-eElectrolytic CAP. 100uF 16V 20% (RoHS) 3C109,C117,C120 135-3226m50-eElectrolytic CAP. 22U 50V 20% (RoHS) 2C114,C118 135-3227m10-eElectrolytic CAP. 220U 10V 20%

21、(RoHS) 2C129,C130 135-3227m16-eElectrolytic CAP. 220U 16V 20% (RoHS) 1C111 135-3476m25-eElectrolytic CAP. 47U 25V 20% (RoHS) 1C103 130-3f472md00-eDISC Capacitor 4700P 400V 20% safe rule long crus (RoHS) 1for Power Switch SW100 132-223ja03-eMYLAR Capacitor 0.022uF 100V 5% (RoHS) 2C123,C127 135-3107m1

22、6-eElectrolytic CAP. 100uF 16V 20% (RoHS) 1C110 135-4688m50-eElectrolytic CAP. 6800U/50V 20% D25X45mm (RoHS) 2C121,C122 Semiconductors 192-027c1815gr-eTransistor 2SC1815GR NPN5Q102,Q111,Q112,Q113,Q118 192-028a1015gr-eTransistor 2SA1015GR PNP2Q114,Q116 192-1572n5551-eTransistor 2N5551 NPN2Q103,Q109 1

23、92-1582n5401-eTransistor 2N5401 AI-PNP 350V2Q104,Q110 197-631n4148-eDIODE 500mW 75V 1N4148 Panjit (RoHS) 4D101,D103,D105,D108 199-65000333g-eZENER DIODE GDZJ3.3A 500mW 3.3V 2% 26mm (RoHS) 1D102 199-65000623g-eZENER DIODE GDZJ6.2B 500mW 6.2V 26mm 2% (RoHS) 2D106,D107 SUB-TS15SUB-TS15 harman/kardonhar

24、man/kardon 23 Part numberDescriptionQtyReference Designator MAIN/POWER PCB 199-65001603g-eZENER DIODE GDZJ16C 500mW 16V 26mm 2% (RoHS) 1D109 190-06m4558d-eI.C. OPA 4558D Dual Op-Amp1U101 192-021tip35c-eTransistor TIP35C NPN1Q107 192-022tip36c-eTransistor TIP36C PNP1Q108 192-027c1815gr-eTransistor 2S

25、C1815GR NPN2Q101,Q115 192-201d882y-eTransistor KSD882Y NPN1Q117 192-202b772y-eTransistor KSB772Y PNP1Q119 192-991d669a-eTransistorHI-SINCERITY HSD669A NPN1Q106 192-992b649t-eTransistor HSB649T PNP1Q105 197-00kbl405-ebridge rectifier 4A 500V KBL405 (RoHS) 1D110 197-101n4002-ediode 1N4002TB (RoHS) 1D1

26、04 Miscellaneous 162-10202001-esingle wire 26AWG 1007 200mm RED 3mm (RoHS) 1 171-udhss124d-erelay 5A 24V UDH-SS124D (RoHS) 1RY101 175-1c07v01-eWIRE CONNECTOR & BASE 7PIN PITCH=2.5mm (RoHS)1P101 175-1d02v01-eWIRE CONNECTOR & BASE 2PIN PITCH=3.96mm (RoHS) 1P102 175-1d03v01-eWIRE CONNECTOR & BASE 3 PIN

27、 PITCH=3.96mm JST-VH (RoHS1P103 193-3m2520-e* INSULATOR TO-3P 25x20mm (RoHS)2for Q107,Q108 323-AL-00020-0LAEHEAT SINK 65*32*31 aluminium color 1 351-AM03014A094-E M3*14 machine screw electrical black (RoHS) 1 352-AM03008D040-E 3*8 B type ping screw electrical black (RoHS) 4 361-FE-00051-0LAETRANSIST

28、OR stator 14.2*8.0*5.2t=1.6mm (RoHS) 1 361-NYL-00054-0LAE TRANSISTOR insulating mat (SW06002) (RoHS) 2 PREAMP PCB Resistors 110-12472j52-eResistor 4.7K 1/2W 5% CF 52mm (RoHS) 2R201,R202 110-16102j26-eResistor 1K 1/6W 5% CF 26mm (RoHS) 6R213,R214,R215,R254,R253,R304 110-16103j26-eResistor 10K 1/6W 5%

29、 CF 26mm (RoHS) 19 R209,R212,R216,R217,R218,R220,R221, R222,R225,R228,R229,R230,R232,R235, R240,R248,R260,R270,R226 110-16104j26-eResistor 100K 1/6W 5% CF 26mm (RoHS) 5R231,R263,R266,R257,R300 110-16105j26-eResistor 1M 1/6W 5% CF 26mm (RoHS) 1R259 110-16113j26-eResistor 11K 1/6W 5% 26mm (RoHS) 1R268

30、 110-16122j26-eResistor 1.2K 1/6W 5% CF 26mm (RoHS) 1R265 110-16123j26-eResistor 12K 1/6W 5% CF 26mm (RoHS) 1R227 110-16124j26-eResistor 120K 1/6W 5% CF 26mm (RoHS) 1R233 110-16152j26-eResistor 1.5K 1/6W 5% CF 26mm (RoHS) 1R302 110-16183j26-eResistor 18K 1/6W 5% CF 26mm (RoHS) 1R262 110-16203j26-eRe

31、sistor 20K 1/6W 5% CF 26mm (RoHS) 2R237,R238 110-16223j26-eResistor 22K 1/6W 5% CF 26mm (RoHS)6R247,R255,R256,R249,R250,R261 110-16303j26-eResistor 30K 1/6W 5% CF 26mm (RoHS) 2R223,R224 110-16472j26-eResistor 4.7K 1/6W 5% CF 26mm (RoHS) 3R200,R207,R258 110-16473j26-eResistor 47K 1/6W 5% CF 26mm (RoH

32、S) 2R219,R264 110-16474j26-eResistor 470K 1/6W 5% CF 26mm (RoHS) 1R251 110-16475j26-eResistor 4.7M 1/6W 5% CF 26mm (RoHS) 1R303 110-16512j26-eResistor 5.1K 1/6W 5% CF 26mm (RoHS) 2R210,R211 110-16684j26-eResistor 680K 1/6W CF 26mm (RoHS) 1R252 110-16752j26-eResistor 7.5K 1/6W 5% CF 26mm TA (RoHS) 1R

33、234 110-16913j26-eResistor 91K 1/6W 5% CF 26mm (RoHS) 4R203,R204,R205,R206 116-169091f26-emetal film Resistor 9.09K 1/6W1% MF 26mm (RoHS) 1R301 115-h503a102-evariable Resistor RV16AE-20B2-15K-A54-104(A50K) LEVEL1VR201 116-201001j5vx-emetalized oxide film Resistor 1K 2W 5% 5mm (RoHS) 1R267 Capacitors

34、 129-a154j633-eMETALIZE CAP. 0.15U 63V 5% MSC (RoHS) 2C221,C222 SUB-TS15SUB-TS15 harman/kardonharman/kardon 24 Part numberDescriptionQtyReference Designator PREAMP PCB 129-a224j633-eMETALIZE CAP. 0.22uF 63V 5% MSC (RoHS) 1C218 130-2b103k503-eDISC Capacitor 0.01u 50V 10% (RoHS) 1C238 130-2b221k503-eD

35、ISC Capacitor 220P 50V 10% (RoHS) 12 C200,C204,C205,C207,C208,C210,C211, C212,C214,C220,C230,C237 130-3f104z503-eDISC Capacitor 0.1U 50V +80/-20% (RoHS) 8 C232,C242,C244,C245,C246,C252,C254, C256 132-183j503-eMYLAR Capacitor 0.018uF 50V 5% (RoHS) 1C223 132-223ja03-eMYLAR Capacitor 0.022uF 100V 5% (R

36、oHS) 1C215 132-473j503-eMYLAR Capacitor 0.047U 50V 5% (RoHS) 1C224 132-563j503-eMYLAR Capacitor 0.056U 50V 5% (RoHS) 1C216 132-823j503-eMYLAR Capacitor 0.056U 50V 5% (RoHS) 1C217 135-3105m50-eElectrolytic CAP. 1U 50V 20% (RoHS) 1C228 135-3106m50-eElectrolytic CAP. 10uF 50V 20% (RoHS) 12 C201,C202,C2

37、06,C213,C219,C231,C241, C243,C251,C253,C248,C247 135-3107m16-eElectrolytic CAP. 100uF 16V 20% (RoHS) 1C234 135-3226m50-eElectrolytic CAP. 22U 50V 20% (RoHS) 1C225 135-3475m16-eElectrolytic CAP.4.7U 16V 20% (RoHS) 1C233 135-3107m50-eElectrolytic CAP. 100U 50V 20% (RoHS) 1C301 135-3227m50-eElectrolyti

38、c CAP. 220uF 50V 20% (RoHS) 1C300 Semiconductors 192-027c1815gr-eTransistor 2SC1815GR NPN4Q201,Q207,Q208,Q206 197-631n4148-eDIODE 500mW 75V 1N4148 Panjit (RoHS) 13 D201,D202,D203,D204,D205,D206,D207, D208,D214,D215,D216,D301,D302 199-65000513g-eZENER DIODE GDZJ5.1B 500mW 5.1V 2% ROHM 1N5231B(RoHS1D2

39、13 190-06m4558d-eI.C. OPA 4558D dual inline (RoHS)1U203 190-06m4558ld-eI.C. NJRC NJM4558LD singlerow inline (RoHS) Dual Op-amp 1U204 190-16tl074cn-eI.C TL074CN ST Quad Op-Amp2U201,U202 197-141n4004-e*DIODE 1N4004 shaping short crus (RoHS)4D217,D218,D219,D220 190-05ps25051-ephotoelectric coupler PS25

40、05-1 NEC (RoHS)1U1 Miscellaneous 162-50122004-edrop-out line 120mm RED/WHT 2PIN (RoHS)1D209 162-5014d008-eWIRE 2468#26AWG RED/WHT length 140mm (RoHS) 1P1-P2 162-a016d001-emixing wire UL1007 160/80mm#26 (RoHS) 1W202 174-0rca313v-eRCA JACK RCA-313G V/R/W (RoHS)1JK201 174-20810360g-ejack SPK JK BP 8PIN

41、 (RoHS) SH0810360G US1.351JK202 174-6ej3556agp-ePHONE JACK EJ3556A-GP (RoHS) 1JK203 175-1b08v01-eWIRE CONNECTOR & BASE 8 PIN PITCH=2.0mm(RoHS)1W202 180-tms7210v-eSWITCH SLIDE 6PIN MS7210V (RoHS) 3SW201,SW202,SW203 362-FE-00041-0LAEPCB support 11.75*8.5*12.5H (RoHS) 2 LIMITER PCB Resistors 110-16103j

42、26-eResistor 10K 1/6W 5% CF 26mm (RoHS) 6R301,R303,R304,R308,R309,R314 110-16153j26-eResistor 15K 1/6W 5% CF 26mm (RoHS) 1R302 110-16223j26-eResistor 22K 1/6W 5% CF 26mm (RoHS) 2R310,R312 110-16333j26-eResistor 33K 1/6W 5% CF 26mm (RoHS) 1R305 110-16474j26-eResistor 470K 1/6W 5% CF 26mm (RoHS) 1R307

43、 110-16751j26-eResistor 750 1/6W 5% CF 26mm (RoHS) 2R311,R313 110-16755j26-eResistor 7.5M 1/6W 5% CF 26mm (RoHS) 1R306 Capacitors 135-3226m50-eElectrolytic CAP. 22U 50V 20% (RoHS) 1C301 135-3476m25-eElectrolytic CAP. 47U 25V 20% (RoHS) 1C304 130-3f104z503-eDISC Capacitor 0.1U 50V +80/-20% (RoHS) 2C3

44、05,C306 SUB-TS15SUB-TS15 harman/kardonharman/kardon 25 Part numberDescriptionQtyReference Designator LIMITER PCB 132-103j503-eMYLAR Capacitor 0.01uF 50V 5% (RoHS) 2C302,C303 Semiconductors 190-16tl074cn-e*I.C TL074CN ST QUAD OP-AMP1U301 192-027c1815gr-e*Transistor 2SC1815GR NPN2Q301,Q302 197-631n414

45、8-eDiode1N4148 26mm 2D301,D302 Miscellaneous 175-9f40hr2-eWIRE CONNECTOR & BASE 40PIN PITCH=2.54mm HR2*40 (RoHS) 162-10059001-esingle wire 50mm WHITE UL1007 AWG26 6:6 (RoHS) 1 162-50159002-eWIRE 7PIN 150mm AWG26 UL 2468 (RoHS) 1P302 MISCELLANEOUS/MECHANICAL 150-e8604107-ePower transformer EI-86 60Hz

46、 120V TT0869906580 1 152-u602015-epower cord joint SVT FT-2 6FT bi-insulation (RoHS) 1 154-u25006t0-efuse 2.5A 250V 20mm (RoHS) 1 155-520020-efuse holder R3-11 (RoHS) 1 162-10082007-eWIRE RED 18AWG 80mm 8mm#1015 (RoHS) 1 162-5020d006-eWIRE UL2468 200mm 2.5mmpitch RED/WHT (RoHS) 1 162-a0452001-eWIRE

47、UL1007 #16 450mm #110/ #205 0.5T (RoHS) 1 176-wjce1-edead end CE-1 (RoHS) 1 180-pbr12c11s-epower PUSH BR12C11S (RoHS) POWER ON-OFF1SW100 302-AL-00435-1BFEaluminium backboard 270*215*2.5T anode blackening (RoHS) 1 306-ABS-00004-0BAE rear housing REAR CABINET 268*213*102 A.B.S UL (RoHS) 1 311-ABS-00028-0BAE plastic KNOB 46077-W soft material P.V.C. (RoHS) LEVEL 1 320-RUB-00033-0BAERUBBER PAD 25*21*4t glue on back (RoHS)4 323-AL-00106-0BBEHEAT SINK 117