HarmanKardon-HKTS7-htss-sm维修电路原理图.pdf

《HarmanKardon-HKTS7-htss-sm维修电路原理图.pdf》由会员分享，可在线阅读，更多相关《HarmanKardon-HKTS7-htss-sm维修电路原理图.pdf（27页珍藏版）》请在收音机爱好者资料库上搜索。

1、harman/kardon SUB-TS7SUB-TS7 (HKTS 7 SUBWOOFER) SERVICE MANUAL harman/kardon, Inc. 250 Crossways Park Dr. Woodbury, New York 11797 Rev1 6/2004 RadioFans.CN CONTENTS BASIC SPECIFICATIONS . . . . . . . . . . . . . . . . 1 DETAILED SPECIFICATIONS . . . . . . . . . . . . . . . . . . . . . . . 2 CONTROLS

2、 or whether it has moved: i.e., the speaker that was not working still has no sound and the speaker that was working is still fine. If the problem is in the same place, the source of the problem is most likely with your receiver or amplifier, and you should consult the owners manual for that product

3、 for further information. If theproblem has followed the speaker, consult your dealer for further assistance or, if that is not possible, visit our Web site at for further information. If there is no sound from Check all wires and connections between receiver/amplifier and speaker. Make sure all wir

4、es are connected. the center speaker:Make sure none of the speaker wires are frayed, ccut, punctured, or touching other wires. If your receiver/processor is set in Dolby Pro Logic mode, make sure the center speaker is not in phantom mode. If your receiver/processor is set in Dolby Digital or DTS mod

5、e, make sure the receiver/processor is configured so that the center speaker is enabled. If the system plays at low Check all wires and connections between receiver/amplifier and speakers. Make sure all wires are connected. volumes but shuts off as Make sure none of the speaker wires are frayed, cut

6、, punctured, or touching other wires. volume is increased: If more than one pair of main speakers is being used, check the minimum impedance requirements of your receiver/amplifier. If there is low (or no) bass Make sure the SUB or Line-Level Inputs of the SUB-TS7 subwoofer and SUB or LFE output of

7、your receiver output:or amplifier are properly connected by the RCA-type interconnect cable. If you are using the SUB-TS7s Speaker-Level Inputs , check your speaker cables to make sure they are all connected; that none of the wires are frayed, cut, punctured, or touching other wires; and that you ha

8、ve maintained the correct polarity by connecting positive terminals to positive terminals, and negative terminals to negative terminals. Make sure the subwoofer is plugged into an active electrical outlet and its Master Power Switch is switched on to the “” position. Check the speaker setup (bass ma

9、nagement) settings in your A/V receiver or processor to make certain that the front, center and surround speakers are configured for “Small,” and that the subwoofer is set for “Yes” or “On.” If there is no sound from Check all wires and connections between receiver/amplifier and speakers. Make sure

10、all wires are connected. Make sure the surround speakers:none of the speaker wires are frayed, cut, punctured, or touching other wires. Review proper operation of your receiver/processor and its surround sound features. Make sure the movie or TV show you are watching is recorded in a surround sound

11、mode. If it is not, check to see whether your receiver/processor has other surround modes you may use. In Dolby Digital or DTS mode, make sure your receiver/processor is configured so that the surround speakers are enabled. Review the operation of your DVD player and the jacket of your DVD to make s

12、ure that the DVD features the desired Dolby Digital or DTS mode, and that you have properly selected that mode using both the DVD players menu and the DVD discs menu. HKTS 7 OM 11/4/03 11:30 AM Page 16 10 SUB-TS7 SUB-TS7 harman/kardon harman/kardon Ref# Description Part Number Qty 1 Amplifier screw

13、352-AM04020D210 10 2 SUB-TS7 Amplifier Not for Sale 1 3 Port Tube Not for Sale 1 4 SUB-TS7 Cabinet Not for Sale 1 5 Logo 316-AG-00557 1 6 LED Not for Sale 1 7 Grille Not for Sale 1 8 Logo 316-AL-00553 1 9 10 woofer 25PF12DZB-DW01 1 10 Woofer screw 352-FM04020D605 5 11 Foot Pad 320-EVA-00057 4 11 SUB

14、-TS7 SUB-TS7 harman/kardon harman/kardon 12 SUB-TS7 SUB-TS7 harman/kardon harman/kardon (See Mechanical Parts List on Pages 21-22) Test Set Up and Procedure Equipment needed: Function/signal generator/sweep generator Integrated Amplifier Multimeter Speaker cables Initial Control Settings: Power Swit

15、ch OFF; Filter OFF Level MIN (Full CCW) Phase, Auto/On switches do not matter General Unit Function (UUT = Unit Under Test) 1) From the signal generator, connect one line level (RCA) cable to the Subwoofer Line Level Input jacks L/R on the UUT. Use a Y-cable from a mono source if necessary to connec

16、t to both inputs. Do not connect to the single, purple SUB input. 2) Turn on generator; adjust to 75mV, 50 Hz. 3) Plug in UUT; turn the power switch ON. Turn LEVEL control full clockwise (MAX) 4) LED should turn from Amber to Blue (on top of UUT); immediate and vigorous bass response should be heard

17、 and felt from port tube opening. 5) Turn off generator, turn LEVEL control full counterclockwise (MIN), and disconnect RCA cable. 6) Connect one pair of speaker cables to Speaker Level input terminal (IN) on UUT. Cables should be connected to an integrated amplifier fed by the signal generator. 7)

18、Turn on generator and adjust so that speaker level input at the amplifier is 1.6V, 50 Hz. Turn LEVEL control full clockwise. 8) LED should turn from Amber to Blue; immediate and vigorous bass response should be heard and felt from the port tube opening. Sweep Function 1) Follow steps 6-8 above, usin

19、g a sweep generator as a signal source. 2) Sweep generator from 20Hz to 300Hz. Listen to the cabinet and drivers for any rattles, clicks, buzzes or any other noises. If any unusual noises are heard, remove woofers and test. Driver Function 1) Remove woofer from cabinet; detach + and - wire clips. 2)

20、 Check DC resistance of woofer; it should be 3.0 ohms 10% 3) Connect a pair of speaker cables to driver terminals. Cables should be connected to an integrated amplifier fed by a signal generator. Turn on generator and adjust so that speaker level output is 5.0V. 4) Sweep generator from 20Hz to 1kHz.

21、 Listen to driver for any rubbing, buzzing, or other unusual noises. SUB-TS7 SUB-TS7 harman/kardon harman/kardon 13 SUB-TS7 SUB-TS7 harman/kardon harman/kardon 14 SUB-TS7 SUB-TS7 harman/kardon harman/kardon 15 SUB-TS7 SUB-TS7 harman/kardon harman/kardon 16 SUB-TS7 SUB-TS7 harman/kardon harman/kardon

22、 17 SUB-TS7 SUB-TS7 harman/kardon harman/kardon 18 SUB-TS7 120V Electrical parts list Part numberDescriptionQtyReference Designator PREAMP PCB Resistors 110- 12472j52resistor 4.7K 1/2W 5% CF 52mm 2R201,202 110- 16102j26resistor 1K 1/6W 5% CF 26mm 4R213,214,215,254 110- 16103j26resistor 10K 1/6W 5% C

23、F 26mm 18 R209,212,216,217,218,220,221,222,225,228,229,230, 232,235, 240,248,260,270 110- 16104j26resistor 100K 1/6W 5% CF 26mm 3R231,263,266 110- 16105j26resistor 1M 1/6W 5% CF 26mm 1R259 110- 16122j26resistor 1.2K 1/6W 5% CF 26mm 1R265 110- 16124j26resistor 120K1/6W 5% CF 26mm 1R233 110- 16151j26r

24、esistor 1501/6W 5% CF 26mm 1R253 110- 16154j26resistor 150K 1/6W 5% CF 26mm 1R252 110- 16182j26resistor 18K 1/6W 5% CF 26mm 1R262 110- 16203j26resistor 20K 1/6W 5% CF 26mm 2R237,238 110- 16205j26resistor 2M 1/6W 5% CF 26mm 2R257 110- 16223j26resistor 22K 1/6W 5% CF 26mm 3R247,255,256 110- 16273j26re

25、sistor 27K 1/6W 5% CF 26mm 2R226,227 110- 16472j26resistor 4.7K 1/6W 5% CF 26mm 3R200,207,258 110- 16473j26resistor 47K 1/6W 5% CF 26mm 5R219,249,250,251,264 110- 16512j26resistor 5.1K 1/6W 5% CF 26mm 2R210,211 110- 16513j26resistor 51K 1/6W 5% CF 26mm 2R223,224 110- 16752j26resistor 7.5K 1/6W 5% CF

26、 26mm 1R234 110- 16913j26resistor 91K 1/6W 5% CF 26mm 4R203,204,205,206 115- h503a103variable resistor RV16AE- 20B2- 15K- A54- 104(A50K) 1VR201 Capacitors 129- a224j633metalize 0.22uF 63V 5% MSC 1C218 130- 2b221k503disc capacitor 220P 50V 10% 12C200,204,205,207,208,210,211,212,214,220,230,237 130- 2

27、b470k503disc capacitor 47P 50V 10% 1C229 130- 2f104z503disc capacitor 0.1U 50V +80/- 20% 8C232,242,244,245,246,252,254,256 132- 183j503mylar capacitor 0.018uF 50V 5% 1C223 132- 223ja03mylar capacitor 0.022uF 100V 5% 1C215 132- 473j503mylar capacitor 0.047U 50V 5% 1C224 132- 563j503mylar capacitor 0.

28、056U 50V 5% 1C216 132- 823j503mylar capacitor 0.082U 50V 5% 1C217 135- 3105m50electrolytic 1U 50V 20% 10C201,202,209,213,219,231,241,243,251,253 135- 3107m16electrolytic 100uF 16V 20% 1C234 135- 3226m50electrolytic 22U 50V 20% 1C225 135- 3227m16electrolytic 220U 16V 20% 1C233 129- a154j633Mylar capa

29、citor 0.15U 63V 5% MSC2C221,222 Semiconductors 192- 027c1815grTransistor 2SC1815GR NPN 3Q201,206,207,208 197- 131n4148diode 1N4148 26mm 11D201,202,203,204,205,206,207,208,214,215,216 199- 15000335zenerdiode 3.3V 1/2W 52mm 1D213 190- 06m4558dI.C. OPA 4558D Dual Op- Amp1U203 190- 16tl074cnI.C TL074CN

30、ST Quad Op- Amp2U201,202 162- 50332003wire 2PIN 330mm RED 1D209 Miscellaneous 174- 0rca313vRCA JACK RCA- 313G V/R/W 1JK201 174- 20810360gJACK SPK JK BP 8PIN SH0810360G US1.35 1JK202 175- 1b08v01wire connector 8 PIN PITCH=2.0mm 1 180- tms7210vSWITCH SLIDE 6PIN MS7210V 3SW201,202,203 19 SUB-TS7 SUB-TS

31、7 harman/kardon harman/kardon Part numberDescriptionQtyReference Designator MAIN PCB Resistors 110- 14472j26resistor 4.7K 1/4W 5% CF 26mm 2R147,150 110- 14681j26resistor 6801/4W 5% CF 26mm 1R148,151 110- 16101j26resistor 1001/6W 5% CF 26mm 1R120 110- 16102j26resistor 1K 1/6W 5% CF 26mm 1R124 110- 16

32、103j26resistor 10K 1/6W 5% CF 52mm 1R134 110- 16105j26resistor 1M 1/6W 5% CF 26mm 1R143 110- 16123j26resistor 12K 1/6W 5% CF 26mm 2R135,139 110- 16152j26resistor 1.5K 1/6W 5% CF 26mm 6R103,123,136,137,141,142 110- 16153j26resistor 15K 1/6W 5% CF 26mm 4R118,145,152,154 110- 16154j26resistor 150K 1/6W

33、 5% CF 26mm 1R131 110- 16181j26resistor 1801/6W 5% CF 26mm 2R111,114 110- 16182j26resistor 1.8K 1/6W 5% CF 26mm 1R153 110- 16223j26resistor 22K 1/6W 5% CF 26mm 3R128,129,133 110- 16332j26resistor 3.3K 1/6W 5% CF 26mm 3R106,107,144 110- 16392j26resistor 3.9K 1/6W 5% CF 26mm 2R105,108 110- 16393j26res

34、istor 39K 1/6W 5% CF 26mm 1R126 110- 16470j26resistor 47 1/6W 5% CF 26mm 4R112,113,115,116 110- 16471j26resistor 470 1/6W 5% CF 26mm 1R140 110- 16472j26resistor 4.7K 1/6W 5% CF 26mm 3R110,125,130 110- 16473j26resistor 47K 1/6W 5% CF 26mm 1R101 110- 16560j26resistor 561/6W 5% CF 26mm 1R117 110- 16563

35、j26resistor 56K 1/6W 5% CF 26mm 1R104 110- 16682j26resistor 6.8K 1/6W 5% CF 26mm 1R109 110- 10821jk2resistor 820 1W 5% 10mm 1R132 110- 122r2j15resistor 2.2 1/2W 5% 15mm 1R127 110- 20331jk2resistor 330 2W 5% 5mm 2R146,149 113- 50r10j10cement resistor 0.1 5W 5% 2R121,122 114- 03302m0semi- fixed resist

36、or 3K 0.3W 20% 1R138 Capacitors 130- 2b102k503disc capacitor 1000P 50V 10% 1C116 130- 2f104z503disc capacitor 0.1U 50V +80/- 20% 4C108,113,115,119 130- 3f473m503disc capacitor 0.047U 50V 20% 1C106 130- sl101k503disc capacitor 100P 50V 10% 2C139,140 132- 104j503mylar capacitor 0.1U 50V 5% 1C107 132-

37、223ja03mylar capacitor 0.022uF 100V 5% 4C124,125,126,128 135- 3105m50electrolytic 1U 50V 20% 2C105,112 135- 3107m16electrolytic 100uF 16V 20% 3C109,117,120 135- 3226m50electrolytic 22U 50V 20% 2C114,118 135- 3227m10electrolytic 220U 10V 20% 2C129,130 135- 3476m25electrolytic 47U 25V 20% 1C103 130- 3

38、f472md00disc capacitor 4700P 400V 20% 1 132- 223ja03mylar capacitor 0.022uF 100V 5% 2C123,127 135- 3107m16electrolytic 100uF 16V 20% 1C110 135- 4688m50electrolytic 6800U/50V 20% D25X45mm 2C121,122 Semiconductors 192- 027c1815grTransistor 2SC1815GR NPN 5Q102,111,112,113,118 192- 028a1015grTransistor

39、2SA1015GR PNP 2Q114,116 192- 1672n5551Transistor 2SN5551 NPN 2Q103,109 192- 1682n5401Transistor 2SN5401AI- PNP 350V 500mA TO- 92 2Q104,110 197- 131n4148diode 1N4148 26mm 4D101,103,105,108 199- 15000335zener diode 3.3V 1/2W 52mm 1D102 199- 15000625zener diode 6.2V 1/2W 52mm 2D106,107 199- 15001605zen

40、er diode 16V 1/2W 52mm 1D109 190- 06m4558dI.C. OPA 4558D DUAL OP- AMP 1U101 192- 021c1815grTransistor 2SC1815GR NPN 2Q101,115 192- 021tip35cTransistor tip35c NPN 1Q107 192- 02tip36cTransistor tip36c PNP 1Q108 192- 201d882yTransistor KSD882Y NPN 1Q117 192- 202b772yTransistor KSB772Y PNP 1Q119 20 SUB-

41、TS7 SUB-TS7 harman/kardon harman/kardon Part numberDescriptionQtyReference Designator MAIN PCB 192- 991d669aTransistorHI- SINCERITY HSD669A NPN 1Q106 192- 992b649tTransistor HSB649T PNP 1Q105 197- 00kb1405diode 4A 500V KBL405 1D110 197- 101n4002diode 1N4002 1D104 Miscellaneous 162- 10202001wire 26AW

42、G 1007 200mm RED 3mm 1 171- udhss124drelay 5A 24V UDH- SS124D 1RY101 175- 1c07v01wire connector 7PIN PITCH=2.5mm 1P101 175- 1d02v01wire connector 2PIN PITCH=3.96mm 1P102 175- 1d03v01wire connector 3PIN PITCH=3.96mm 1P103 193- 3m2520insulator TO- 3P 25x20mm 2Q107,108 150- e8604107power ansformer EI-

43、86 60Hz 120V TT0869906580 1 152- u602015line cord SVT FT- 2 6FT 1 154- u25006t0fuse 2.5A 250V 20mm 1 155- 520020fuse holder R3- 11 1 162- 10082007WIRE RED 18AWG 80mm 8mm#1015 1 162- a040d001WIRE #1015 400mm 991110- 00 2 163- 11009wire tie 100mm 2 176- wjcelwire connector PIN CE- 1 1 180- pbr12c11ssw

44、itch PUSH BR12C11S 1 LIMITER PCB Resistors 110- 16103j26resistor 10K 1/6W 5% CF 26mm 6R301,303,304,308,309,314 110- 16153j26resistor 15K 1/6W 5% CF 26mm 1R302 110- 16223j26resistor 22K 1/6W 5% CF 26mm 2R310,312 110- 16333j26resistor 33K 1/6W 5% CF 26mm 1R305 110- 16474j26resistor 470K 1/6W 5% CF 26m

45、m 1R307 110- 16751j26resistor 750K 1/6W 5% CF 26mm 2R311,313 110- 16755j26resistor 7.5M 1/6W 5% CF 26mm 1R306 Capacitors 130- 2f104z503disc capacitor 0.1U 50V +80/- 20% 2C305,306 132- 103j503mylar capacitor 0.01U 50V 5% 2C302,303 135- 3226m50electrolytic 22U 50V 20% 1C301 135- 3476m25electrolytic 47U 25V 20%