McIntosh-MC2KW-pwr-sm维修电路原理图.pdf

《McIntosh-MC2KW-pwr-sm维修电路原理图.pdf》由会员分享，可在线阅读，更多相关《McIntosh-MC2KW-pwr-sm维修电路原理图.pdf（28页珍藏版）》请在收音机爱好者资料库上搜索。

1、Performance Specifications . 2 Notes MC2KW. 3 POWER MODULE Rear Panel . 3 Section Location . 3 Block Diagram . 4 Interconnection Diagram . 5 - 6 Amp Schematic and PCB . 7 - 9 Heatsink Schematic and PCB . 10 - 11 Heatsink Slave Schematic and PCB . 12 - 13 Capacitor Schematic and PCB . 14 Logo Schemat

2、ic and PCB . 15 Logo Schematic and PCB . 16 Parts List . 17 - 19 OUTPUT MODULE Rear Panel . 20 Section Location . 20 Interconnection Diagram . 21 - 22 Main Schematic and PCB . 23 - 28 Meter Power Supply Schematic and PCB. 29 - 32 Meter Led Schematic and PCB . 33 - 34 Parts List . 35 - 37 Repacking I

3、nstruction . 39 POWER MODULE CONTENTS OUTPUT MODULE SERVICE MANUAL POWER AMPLIFIER PRELIMINARY SERIAL NO. POWER MODULE WJ-A001 And Above POWER MODULE WJ-B001 And Above OUTPUT MODULE WJ-C001 And Above RadioFans.CN 收音机爱 好者资料库 PERFORMANCE SPECIFICATIONS Power Output 2000 watts into an 8, 4 or 2 ohm loa

4、d is the minimum sine wave continuous average power output. The output RMS voltage is: 126.5V across 8 ohms 89.5V across 4 ohms 62.2V across 2 ohms Output Load Impedance 8, 4 and 2 ohms (with three paors of terminals each for impedance) Rated Power Band 20Hz to 20,000Hz Total Harmonic Distortion 0.0

5、05% maximum harmonic distortion at any power level from 250 milliwatts to 2000 watts, 20Hz to 20,000Hz Dynamic Headroom 2dB Frequency Response +0, -0.25dB from 20Hz to 20,000Hz +0, -3dB from 10Hz to 100,000Hz Sensitivity 5.0 Volts Balanced Input 2.5 Volts Unbalanced Input A-Weighted Signal To Noise

6、Ratio 90dB Unbalanced (123dB below rated output) 94dB Balanced (127dB below rated output) Intermodulation Distortion 0.005% maximum, if instantaneous peak power output does not exceed 4000 watts, for any combination of frequencies from 20Hz to 20kHz. Wide Band Damping Factor Greater than 40 Input Im

7、pedance 10,000 ohms Power Guard Less than 2% THD with up to 14dB overdrive General Specifications MC2KW Output Module Power Requirements 100 Volts, 50/60Hz at 35 watts 110 Volts, 50/60Hz at 35 watts 120 Volts, 50/60Hz at 35 watts 220 Volts, 50/60Hz at 35 watts 230 Volts, 50/60Hz at 35 watts 240 Volt

8、s, 50/60Hz at 35 watts MC2KW Power Module Power Requirements1 100 Volts, 50/60Hz at 1440 watts 110 Volts, 50/60Hz at 13.0 amps 120 Volts, 50/60Hz at 12 amps 220 Volts, 50/60Hz at 7.5 amps 230 Volts, 50/60Hz at 6.5 amps 240 Volts, 50/60Hz at 6.5 amps Note: Refer to the rear panels of the MC2KW Output

9、 Module and MC2KW Power Modules for the correct voltage. Overall Dimensions MC2KW Output Module: Width is 17-3/4 inches (45.09cm), Height us 12-5/16 inches (31.27cm) including feet, Depth is 26-5/ 8 inches (62.54cm) including the front panel, handles, knobs and interconnect cables2 MC2KW Power Modul

10、e: Width is 17-3/4 inches (45.09cm), Height us 12-5/16 inches (31.27cm) including feet, Depth is 26-5/ 8 inches (62.54cm) including the front panel, handles and interconnect cables2 Weight MC2KW Output Module is 121 poulds (54.9kg) net, 146 pounds (66.2kg) in shipping carton MC2KW Power Module is 15

11、8 poulds (71.7kg) net, 183 pounds (83.0kg) in shipping carton 1 The power requirements listed are for each MC2KW Power Module, two are required for each MC2KW Power Amplifier 2 Interconnect cables are supplied with the MC2KW Output Module and both MC2KW Power Modules connect to the MC2KW Output Modu

12、le. 2 1. The heavy notes on the schematic denote the primary signal path. 2. Unless otherwise noted, all voltages indicated on the schematics are measured under the following conditions: a. AC input at 120 volts, 50/60Hz. b. All voltages are +/-10% with respect to ground. A high impedance (10 megaoh

13、m) voltmeter must be used. 3. Unless otherwise specified: a. Resistor values are in ohms. b. Capacitor values are microfarads (uF). c. Inductor values are in microhenries (uH). 4. On PC board drawings, Square pad indicates: a. Polarized Capacitors - Positive b. Diodes - Cathode c. Others - Pin 1 5.

14、WARNING Parts marked with the symbol have critical characteristics. Use only replacement parts recom- mended by the manufacturer. 6. Soft startup procedure for servicing: 1. Interconnect output module and power modules 2. Connect Output Module to 120VAC 3. Connect Power Modules to variac and set the

15、 output to zero. 4. Turn Output Module power switch to on. (This will energize the power relays in the Power Modules.) 5. Gradually advance the variac to 120VAC while monitoring the AC current. NOTES RadioFans.CN 收音机爱 好者资料库 3 REAR PANEL SECTION LOCATION TOP VIEW WITH COVER REMOVED MC2KW POWER RadioF

16、ans.CN 收音机爱 好者资料库 4 BLOCK DIAGRAM RadioFans.CN 收音机爱 好者资料库 INTERCONNECT MC2KW OUTPUT 56 1 RadioFans.CN 收音机爱 好者资料库 78 AMP 050215 SCH2 RadioFans.CN 收音机爱 好者资料库 AMP 050215 PCB2 910 HEATSINK 050216 SCH3A MC2KW POWER 3B RadioFans.CN 收音机爱 好者资料库 HEATSINK 050216 PCB 3A 1112 3BHEATSINK SLAVE 050282 SCH4A 4B Ra

17、dioFans.CN 收音机爱 好者资料库 J2 R2 R5 129610 J4 J6 GP2 GP3 R4 R7 R1 GP1 R3 J1 R6 GP4 J5 R13 R15 Q11 R21 R23 Q19 C10 R14 Q10 R16 R20 RT1 R22 Q18 C11 J3 Q9 R19 R17 Q17 Q15Q13 R12 Q8 R18 Q12Q14 Q16 TO RED Rev.A BLU MASTER HS GRN MC2KW POWER HEATSINK SLAVE 050282 4A 4B 13 RadioFans.CN 收音机爱 好者资料库 4 3 4 3 1 1 3

18、4 3 4 -80V J6 -80V J6 80V J5 80V J5 GRN RED GP1 80V -80V -80V -80V J6 J6 80V 80V J5 J5 RECT- J2 RECT+J1 J7 J8 J9 J10 J3 J4 J5 J6 C1 67000uF C2 67000uF + + J7 J8 J10 129592 J1 J3 J5 J4 J9 J6 J2 GP1 RED RED GRN GRN RED GRN Rev.A RED RED GRN GRN 5CAPACITOR 050217 14 RadioFans.CN 收音机爱 好者资料库 LOGO 050218

19、6A B+ 15V 6B 6B 2 2 NC 15V 6B 2 2 15V 15V 15V GREEN GREEN J5:2 J5:1 J5:2 J5:1 15V GREEN DS7 1.65k R4 DS5 1.65k R3 GREEN DS1 1.65k R1 1k R9 15V J5:3 J5:4 J5:3 DS2 1.65k R2 GREEN GREEN LOGO1 J2:1 LOGO1 LOGO1 J1:1 GREEN DS8 DS6 GREEN DS3 J2:3 J2:2 15V J1:4 J1:2 J1:3 DS4 MC2KW POWER 15 RadioFans.CN 收音机爱

20、 好者资料库 S9 B+ NC LOGO2 6AJ2:3 6AJ2:2 D 6AJ2:1 J5:3 J5:1 J5:2 LOGO 050218 6B 16 RadioFans.CN 收音机爱 好者资料库 PARTS LIST INTERCONNECT T1POWER TRANSFORMER050230 D1DIODE BRIDGE RECT070181 RT1ASSY THERMISTOR052017 RT2ASSY THERMISTOR052017 CBCIRCUIT BREAKER 20A 240V088022 AMPLIFIER PCB 050215 C1CAP MONO 10PF 20

21、0V 10%061297 C2CAP ELECT 100UF 25V066447 C3CAP MONO .1UF 50V 20%061305 C4CAP MONO .1UF 50V 20%061305 C5CAP MONO .1UF 50V 20%061305 C6CAP ELECT 10UF 50V066445 C7CAP ELECT 22UF 100V066506 C8CAP MONO .1UF 50V 20%061305 C9CAP MONO .1UF 50V 20%061305 C10CAP ELECT 10UF 50V066445 C11CAP ELECT 100UF 25V0664

22、47 C12CAP ELECT 10UF 100VDC066462 C13CAP MONO 1PF 100V NPO061319 C14CAP ELECT 10UF 100VDC066462 C15CAP MONO 220PF 200V 10%061301 C16CAP MONO 470PF 100V 10%061302 C17CAP MONO 1000PF 50V 10%061303 C18CAP MONO 1000PF 50V 10%061303 C19CAP MONO 100PF 100V 10%061300 C20CAP MONO 100PF 100V 10%061300 C21CAP

23、 ELECT 220UF 25V066507 C22CAP MONO 47PF 200V 10%061299 C23CAP MONO 47PF 200V 10%061299 C24CAP MONO 47PF 200V 10%061299 C25CAP MONO .1UF 50V 20%061305 C26CAP MONO .1UF 50V 20%061305 D1DIODE SILICON070047 D2DIODE SILICON070047 D3DIODE SILICON070047 D4DIODE SILICON070047 D5DIODE SILICON070047 D6DIODE S

24、IL 400 PIV 1.5A070031 D7DIODE SIL 400 PIV 1.5A070031 D8DIODE SILICON070047 D9DIODE SILICON070047 D10DIODE SILICON070047 J1HDR SHROUDED 2ROW 26PIN V117870 J2CONN 3 POS M MTS100 NRML117214 J3CONN 8 POS M FRICTION LOCK117275 J4CONN 8 POS M FRICTION LOCK117275 J5CONN 3 POS M MTS100 NRML117214 J6BLADE FA

25、STON W/FEET117708 J7BLADE FASTON W/FEET117708 J8HEADER 8 PIN MTA-156117717 J9HEADER 8 PIN MTA-156117717 J10BLADE FASTON W/FEET117708 J11BLADE FASTON W/FEET117708 J12BLADE FASTON W/FEET117708 J13BLADE FASTON W/FEET117708 J15CONN 4 PIN117215 J16BLADE FASTON W/FEET117708 K1RELAY POWER 24VDC/TV-15087042

26、 Q1TRANSISTOR PNP132224 Q2TRANSISTOR PNP POWER132255 Q3TRANSISTOR NPN132223 Q4TRANSISTOR PNP132224 Q5TRANSISTOR NPN132223 Q6TRANSISTOR PNP132224 Q7TRANSISTOR PNP132224 Q8TRANSISTOR PNP 2SA1321C132286 Q9TRANSISTOR NPN 2SC3334C132285 Q10TRANSISTOR N JFET132222 Q11TRANSISTOR N JFET132222 Q12TRANSISTOR

27、SI NPN 25V132254 Q13TRANSISTOR PNP POWER132255 Q14TRANSISTOR PNP132224 Q15TRANSISTOR NPN132223 Q16TRANSISTOR SI NPN 25V132254 Q17TRANSISTOR PNP POWER132255 Q18TRANSISTOR NPN132223 Q19TRANSISTOR PNP132224 Q20TRANSISTOR SI NPN 25V132254 Q21TRANSISTOR PNP POWER132255 Q22TRANSISTOR NPN 2SC3334C132285 Q2

28、3TRANSISTOR PNP SILICON132172 Q24TRANSISTOR PNP 2SA1321C132286 Q25TRANSISTOR NPN 2SC3334C132285 Q26TRANSISTOR NPN SILICON132171 Q27TRANSISTOR PNP 2SA1321C132286 Q28TRANSISTOR PNP 2SA1321C132286 Q29TRANSISTOR NPN 2SC3334C132285 Q30TRANSISTOR NPN132223 Q31TRIAC OPTOCOUPLER131024 Q32TRANSISTOR PNP SILI

29、CON132172 Q33TRANSISTOR PNP 2SA1321C132286 Q34TRANSISTOR NPN 2SC3334C132285 Q35TRANSISTOR NPN SILICON132171 Q36TRANSISTOR NPN132223 R1RES MF 47.5K 1% 1/4W144108 R2RES MF 2.21K .5% 1/4W144396 R3RES MF 2.21K .5% 1/4W144396 R4RES MET OX 430 OHM .5W 5%137095 R5RES MF 47.5K 1% 1/4W144108 R6RES MF 4.75K 1

30、% 1/4W144097 R7RES MF 475 OHM 1% 1/4W144086 R8RES MF 47.5K 1% 1/4W144108 R9RES MF 1.91K .5% 1/4W144395 R10RES MF 47.5K 1% 1/4W144108 R11RES MF 1.91K .5% 1/4W144395 R12RES MF 221K 1% 1/4W144421 R13RES MF 475 OHM 1% 1/4W144086 R14RES MF 100 OHM 1% 1/4W144196 R15RES MET OX 430 OHM .5W 5%137095 R16RES M

31、F 100 OHM 1% 1/4W144196 R17RES MF 1K 1% 1/4W144090 R18RES MF 100 OHM 1% 1/4W144196 R19RES MF 100 OHM 1% 1/4W144196 R20RES MF 3.32K 1% 1/4W144095 R21RES MF 2.21M 1/4W144265 R22RES MF 1K 1% 1/4W144090 R23RES MF 475K 1% 1/4W144364 R24RES MET OX 47 OHM .5W 5%137096 R25RES MET OX 680 OHM .5W 5%137093 MC2

32、KW POWER 17 Ref. No.DescriptionPart No. 1 2 RadioFans.CN 收音机爱 好者资料库 R26RES MF 1K 1% 1/4W144090 R27RES MF 475K 1% 1/4W144364 R28RES MET OX 47 OHM .5W 5%137096 R29RES MF 47.5K 1% 1/4W144108 R30RES MF 47.5K 1% 1/4W144108 R31RES MF 2.21K 1% 1/4W144298 R32RES MF 2.21K 1% 1/4W144298 R33RES MF 221 OHM 1% 1

33、/4W144172 R34RES MF 221 OHM 1% 1/4W144172 R35RES MF 806 OHM 1% 1/4W144089 R36RES MF 806 OHM 1% 1/4W144089 R37RES MF 221 OHM 1% 1/4W144172 R38RES MF 221 OHM 1% 1/4W144172 R39RES MF 681 OHM 1% 1/4W144195 R40RES MF 681 OHM 1% 1/4W144195 R41RES MF 267K 1% 1/4W144118 R42RES MF 1.5K 1% 1/4W144128 R43RES M

34、F 365 OHM 1% 1/4W144071 R44RES MF 221 OHM 1% 1/4W144172 R45RES MF 221 OHM 1% 1/4W144172 R46RES MF 6.49K .5% 1/4W144401 R47RES MF 5.36K .5% 1/4W144399 R48RES MET OX 680 OHM .5W 5%137093 R49RES MF 5.36K .5% 1/4W144399 R50RES FP 10 OHM 5% 1/4W137025 R51RES FP 10 OHM 5% 1/4W137025 R52RES FP 10 OHM 5% 1/

35、4W137025 R53RES FP 10 OHM 5% 1/4W137025 R54POT 500 OHMS LINEAR 20%134396 R55RES MF 22.1K 1% 1/4W144187 R56RES MET OX 1.8k .5W 5%137094 R57RES MF 22.1K 1% 1/4W144187 R58RES MF 1.5K 1% 1/4W144128 R59RES MF 475 OHM 1% 1/4W144086 R60RES MF 10K 1% 1/4W144053 R61RES MET OX 430 OHM .5W 5%137095 R62RES MF 2

36、21 OHM 1% 1/4W144172 R63RES MF 221 OHM 1% 1/4W144172 R64RES MET OX 1.8k .5W 5%137094 R65RES MF 15K 1% 1/4W144412 R66RES MET OX 430 OHM .5W 5%137095 R67POT 500 OHMS LINEAR 20%134396 U1IC OPERTIONAL AMP LOW NSE133067 U2IC OPERTIONAL AMP LOW NSE133067 HEATSINK PCB 050216 C2CAP MONO .01UF 50V 20% X7R061

37、304 C3CAP ELECT 47UF 35V066446 C4CAP ELECT 47UF 35V066446 C5CAP MONO .01UF 50V 20% X7R061304 C8CAP DISC MONO .47UF 50V061249 C10CAP POLYPROP 1uF 160V 5%064451 C11CAP POLYPROP 1uF 160V 5%064451 D1DIODE SILICON070047 D2DIODE SILICON070047 D3DIODE SILICON070047 D4DIODE SILICON070047 D5DIODE SILICON0700

38、47 D6DIODE SILICON070047 D7DIODE SILICON070047 GP1STANDOFF 6-32 X 1/4 PCB MNT112130 GP2STANDOFF 6-32 X 1/4 PCB MNT112130 GP3STANDOFF 6-32 X 1/4 PCB MNT112130 GP4STANDOFF 6-32 X 1/4 PCB MNT112130 HS1HEATSINK018787 J1CONN 8 POS M FRICTION LOCK117275 J2BLADE FASTON W/FEET117708 J3CONN 3 POS M MTS100 NR

39、ML117214 J4CONN 2 POS RIGHT ANGLE117274 J5BLADE FASTON W/FEET117708 J6BLADE FASTON W/FEET117708 Q2TRANSISTOR NPN SILICON132171 Q3TRANSISTOR PNP SILICON132172 Q6TRANSISTOR MJE15032 NPN132288 Q7TRANSISTOR MJE15033 PNP132289 Q8TRANS NPN THERMTRAK132300 Q9TRANS PNP THERMTRAK132301 Q10TRANS NPN THERMTRAK

40、132300 Q11TRANS PNP THERMTRAK132301 Q12TRANS NPN THERMTRAK132300 Q13TRANS PNP THERMTRAK132301 Q14TRANSR NPN THERMTRAK132300 Q15TRANSR PNP THERMTRAK132301 Q16TRANSR NPN THERMTRAK132300 Q17TRANS PNP THERMTRAK132301 Q18TRANS NPN THERMTRAK132300 Q19TRANS PNP THERMTRAK132301 R1RES MF 1K 1% 1/4W144090 R2R

41、ES MF 2.21 OHM 1% 1/4W144378 R3RES MF 1K 1% 1/4W144090 R4RES MET OX 220 OHM .5W 5%137097 R5RES MET OX 220 OHM .5W 5%137097 R6RES MF 22.1K 1% 1/4W144187 R7RES MF 22.1K 1% 1/4W144187 R8RES MET OX 680 OHM .5W 5%137093 R9RES MET OX 680 OHM .5W 5%137093 R11RES MET OX 47 OHM .5W 5%137096 R12RES WW .68 OHM

42、 5W 5%139245 R13RES WW .68 OHM 5W 5%139245 R14RES WW .68 OHM 5W 5%139245 R15RES WW .68 OHM 5W 5%139245 R16RES WW .68 OHM 5W 5%139245 R17RES WW .68 OHM 5W 5%139245 R18RES WW .68 OHM 5W 5%139245 R19RES WW .68 OHM 5W 5%139245 R20RES WW .68 OHM 5W 5%139245 R21RES WW .68 OHM 5W 5%139245 R22RES WW .68 OHM

43、 5W 5%139245 R23RES WW .68 OHM 5W 5%139245 R25RES MF 2.21 OHM 1% 1/4W144378 R26RES MF 2.21 OHM 1% 1/4W144378 R27RES MF 2.21 OHM 1% 1/4W144378 RT1SENSOR THERMAL144249 HEATSINK SLAVE PCB 050282 C10CAP POLYPROP 1uF 250V 5%064451 C11CAP POLYPROP 1uF 250V 5%064451 GP1STANDOFF 6-32 X 1/4 PCB MNT112130 GP2

44、STANDOFF 6-32 X 1/4 PCB MNT112130 GP3STANDOFF 6-32 X 1/4 PCB MNT112130 GP4STANDOFF 6-32 X 1/4 PCB MNT112130 HS1HEATSINK018787 J1CONN 3 POS M MTS100 NRML117214 J2BLADE FASTON W/FEET117708 PARTS LIST cont 18 3A 3B 4A 4B RadioFans.CN 收音机爱 好者资料库 J3CONN 3 POS M MTS100 NRML117214 J4CONN 2 POS RIGHT ANGLE1

45、17274 J5BLADE FASTON W/FEET117708 J6BLADE FASTON W/FEET117708 Q8TRANS NPN THERMLTRAK132300 Q9TRANS PNP THERMLTRAK132301 Q10TRANS NPN THERMLTRAK132300 Q11TRANS PNP THERMLTRAK132301 Q12TRANS NPN THERMLTRAK132300 Q13TRANS PNP THERMLTRAK132301 Q14TRANS NPN THERMLTRAK132300 Q15TRANS PNP THERMLTRAK132301

46、Q16TRANS NPN THERMLTRAK132300 Q17TRANS PNP THERMLTRAK132301 Q18TRANS NPN THERMLTRAK132300 Q19TRANS PNP THERMLTRAK132301 R1RES MF 1K 1% 1/4W144090 R2RES MF 2.21 OHM 1% 1/4W144378 R3RES MF 1K 1% 1/4W144090 R4RES MF 2.21 OHM 1% 1/4W144378 R5RES MF 2.21 OHM 1% 1/4W144378 R6RES MF 2.21 OHM 1% 1/4W144378 R7RES MET OX 47 OHM .5W 5%137096 R12RES WW .68 OHM 5W 5%139245 R13RES WW .68 OHM 5W 5%139245 R14RES WW .68 OHM 5W 5%139245 R15RES WW .68 OHM 5W 5%139245 R16RES WW .68 OHM 5W 5%139245 R17RES WW .68 OHM 5W 5%139245 R18RES WW .68 OHM 5W 5%139245 R19RES WW .68 OHM 5W 5%139245 R20RES WW .68 OHM 5W