Aiwa-CDC-X2179-Service-Manual 电路图 维修手册.pdf

《Aiwa-CDC-X2179-Service-Manual 电路图 维修手册.pdf》由会员分享，可在线阅读，更多相关《Aiwa-CDC-X2179-Service-Manual 电路图 维修手册.pdf（20页珍藏版）》请在收音机爱好者资料库上搜索。

1、SERVICE MANUAL DATA STEREO CAR CD RECEIVER CDC-X417 CDC-X2179 YC YL S/M Code No. 09-018-441-1S2 SUPPLEMENT BASIC CD MECHANISM: BZG-3 ANF This Service Manual contains information about the difference between CDC-X417 / CDC-X2179 and CDC-X4170 / CDC-X2170. If requiring the other information,see Servic

2、e Manual of CDC-X217 / X2170 / X3170 / X4170, (S/M Code No. 09-012-441-1R2). RadioFans.CN 收音机爱 好者资料库 2 SPECIFICATIONS RADIO SECTION (FM) Frequency Range87.5 MHz 108 MHz (100-kHz steps)* 87.5 MHz 108 MHz (50-kHz steps)* Usable Sensitivity12.7 dBf 50 dB Quieting Sensitivity 17.2 dBf IF Rejection80 dB

3、Frequency Response30 Hz 15,000 Hz S/N Ratio63 dB Stereo Separation35 dB at 1 kHz Alternate Channel Selectivity 70 dB Capture Ratio3 dB (AM) Frequency Range530 kHz 1,710 kHz (10-kHz steps)* 531 kHz 1,602 kHz (9-kHz steps)* Usable Sensitivity30 V (30 dB) 9K 10K * Set the frequency increment for your a

4、rea using the switch on the bottom of the unit. (The switch is set at the factory to the 10k position for the U.S.A.) CD SECTION Frequency Response17 Hz 20 kHz +0/3 dB Dynamic RangeMore than 80 dB Channel SeparationMore than 65 dB S/N RatioMore than 85 dB Wow/FlutterUnmeasurable AUDIO SECTION Max. P

5、ower Output45 W x 4 channels AUX IN input Input Sensitivity (Load Impedance) AUX IN300 mV (10 k) GENERAL Power Supply Voltage14.4 V (11 to 16 V allowable), DC, negative ground Load Impedance4 Tone ControlBass 10 dB at 100 Hz Treble 10 dB at 10 kHz Preamp Output Voltage (Load Impedance) 2.2 V (10 k)

6、Installation Size182 (W) x 53 (H) x 155 (D) mm (71/4 (W) x 21/8 (H) x 61/8 (D) inches) STEERING-WHEEL-MOUNTED REMOTE CONTROL UNIT DimensionsApprox. 67 (W) x 26 (H) x 27 (D) mm (23/4 (W) x 11/16 (H) x 11/8 (D) inches) (excluding holder) WeightApprox. 38g (1.33 oz.) (including holder, battery) Design

7、and specifications are subject to change without notice. RadioFans.CN 收音机爱 好者资料库 KANRI NO. REF. NO.DESCRIPTIONPART NO.KANRI NO. REF. NO.DESCRIPTIONPART NO. 3 ELECTRICAL MAIN PARTS LIST IC 87-A20-446-010 C-IC,LA9241ML 87-A21-319-010 C-IC,LC78622NE 87-A21-488-040 C-IC,LA6556 8Z-KT1-622-010 C-IC,LC7537

8、4E 87-A21-562-010 IC,LA4743B 88-KT1-606-080 IC,PST994D 87-A22-064-030 C-IC,LC72358N-9A44 87-A21-489-030 C-IC,LC75853NW 87-A90-951-010 RCR UNIT,SBX1971-52 TRANSISTOR 89-324-122-040 C-TR,2SC2412KR 87-A30-289-040 C-TR,2SA1037AK(Q) 87-A30-288-040 C-TR,DTC114YKA 87-A30-287-040 C-TR,DTC114TKA 87-A30-435-0

9、40 C-TR,DTC144EKA 87-A30-299-080 TR,2SB1326 87-A30-282-040 C-TR,DTA114TKA 89-213-750-010 TR,2SB1375 (25W) 89-420-120-010 TR,2SD2012 (25W) 87-A30-427-040 C-TR,DTC114EKA 87-A30-301-080 TR,2SD1862 DIODE 87-A40-250-040 C-DIODE,DAN217 87-001-783-080 DIODE,1N4002 87-020-331-080 CHIP-DIODE,DAN202K 87-A40-6

10、50-080 ZENER,MTZJ6.8A 87-A40-523-080 ZENER,MTZJ9.1B 87-070-136-080 ZENER,MTZJ5.1B 87-017-932-080 ZENER,MTZJ6.2B 87-070-334-080 ZENER,MTZJ10B 87-A40-798-010 DIODE,1N5402 (3A/200V) 87-A40-817-040 C-ZENER,STZ6.8N 87-020-465-080 DIODE,1SS133 MAIN C.B C101 87-012-274-080 CHIP CAP,U 1000P-50B C102 87-012-

11、286-080 CAP, U 0.01-25 C103 87-010-495-040 CAP,E 2.2-50 GAS C106 87-012-282-080 CAP, U 4700P-50 C107 87-010-552-040 CAP,E 22-16 GAS C108 87-012-195-080 C-CAP,U 100P-50CH C109 87-010-553-040 CAP,E 47-16 GAS C110 87-010-787-080 CAP, U 0.022-25 C111 87-010-553-040 CAP,E 47-16 GAS C112 87-012-281-080 C-

12、CAP,U 3900P-50 B C113 87-012-286-080 CAP, U 0.01-25 C114 87-010-759-080 C-CAP,U, 0.1-25F C115 87-010-759-080 C-CAP,U, 0.1-25F C116 87-010-759-080 C-CAP,U, 0.1-25F C131 87-A11-228-080 C-CAP,U 0.027-25 K B C132 87-A11-228-080 C-CAP,U 0.027-25 K B C133 87-A10-707-080 C-CAP,U 0.47U-16 F Z C134 87-A10-70

13、7-080 C-CAP,U 0.47U-16 F Z C140 87-012-282-080 CAP, U 4700P-50 C173 87-012-195-080 C-CAP,U 100P-50CH C176 87-012-286-080 CAP, U 0.01-25 C201 87-010-553-040 CAP,E 47-16 GAS C202 87-010-553-040 CAP,E 47-16 GAS C203 87-012-274-080 CHIP CAP,U 1000P-50B C204 87-A10-260-080 C-CAP,U 0.1-16 K B C205 87-A10-

14、353-080 C-CAP,U0.22-10KB C206 87-010-492-040 CAP,E 0.33-50 GAS C207 87-010-956-080 CHIP-CAP,S 0.068-25B C208 87-012-272-080 C-CAP,U 680P-50 B C209 87-A10-504-080 C-CAP,U 0.047-16 K B C210 87-A10-260-080 C-CAP,U 0.1-16 K B C211 87-010-498-040 CAP,E 10-16 GAS C212 87-012-276-080 CAP, CHIP SS 1500 PBK

15、C213 87-A10-504-080 C-CAP,U 0.047-16 K B C214 87-A10-260-080 C-CAP,U 0.1-16 K B C215 87-012-278-080 C-CAP,U 2200P-50 B C216 87-A10-353-080 C-CAP,U 0.22-10 K B C217 87-A10-260-080 C-CAP,U 0.1-16 K B C218 87-010-787-080 CAP, U 0.022-25 C219 87-012-268-080 C-CAP,U 330P-50 B C220 87-012-280-080 CAP, U 3

16、300P-50 C221 87-012-195-080 C-CAP,U 100P-50CH C222 87-010-492-040 CAP,E 0.33-50 GAS C223 87-010-067-040 CAP,E 0.1-50 5L C224 87-010-553-040 CAP,E 47-16 GAS C225 87-012-280-080 CAP, U 3300P-50 C226 87-010-497-040 CAP,E 4.7-35 GAS C227 87-010-555-040 CAP,E 100-10 GAS C228 87-A10-260-080 C-CAP,U 0.1-16

17、 K B C229 87-010-498-040 CAP,E 10-16 GAS C230 87-A10-260-080 C-CAP,U 0.1-16 K B C231 87-010-555-040 CAP,E 100-10 GAS C232 87-A10-260-080 C-CAP,U 0.1-16 K B C233 87-010-555-040 CAP,E 100-10 GAS C234 87-010-828-080 CHIP CAPACITOR,U 0.033-25F C235 87-A10-504-080 C-CAP,U 0.047-16 K B C236 87-010-067-040

18、 CAP,E 0.1-50 5L C237 87-010-553-040 CAP,E 47-16 GAS C238 87-012-286-080 CAP, U 0.01-25 C240 87-A10-260-080 C-CAP,U 0.1-16 K B C250 87-A10-047-080 C-CAP,U 1-10 Z F C251 87-010-555-040 CAP,E 100-10 GAS C252 87-A10-260-080 C-CAP,U 0.1-16 K B C253 87-A10-260-080 C-CAP,U 0.1-16 K B C254 87-A10-260-080 C

19、-CAP,U 0.1-16 K B C256 87-012-282-080 CAP, U 4700P-50 C258 87-012-168-080 C-CAP,U 6P-50 CH C259 87-012-184-080 C-CAP,U 33P-50 CH C261 87-012-199-080 CAP 220P C262 87-A10-260-080 C-CAP,U 0.1-16 K B C263 87-010-555-040 CAP,E 100-10 GAS C264 87-010-555-040 CAP,E 100-10 GAS C265 87-A10-260-080 C-CAP,U 0

20、.1-16 K B C266 87-A10-260-080 C-CAP,U 0.1-16 K B C267 87-010-498-040 CAP,E 10-16 GAS C268 87-010-498-040 CAP,E 10-16 GAS C269 87-012-276-080 CAP, CHIP SS 1500 PBK C270 87-012-276-080 CAP, CHIP SS 1500 PBK C271 87-012-172-080 CAPACITOR CHIP U 10P CH C272 87-012-172-080 CAPACITOR CHIP U 10P CH C273 87

21、-010-494-040 CAP,E 1-50 GAS C274 87-010-494-040 CAP,E 1-50 GAS C280 87-A10-189-040 CAP,E 220-10 C281 87-010-555-040 CAP,E 100-10 GAS C282 87-A10-260-080 C-CAP,U 0.1-16 K B C301 87-010-498-040 CAP,E 10-16 GAS C302 87-010-498-040 CAP,E 10-16 GAS C303 87-010-494-040 CAP,E 1-50 GAS C304 87-010-494-040 C

22、AP,E 1-50 GAS C305 87-012-280-080 CAP, U 3300P-50 C306 87-012-280-080 CAP, U 3300P-50 C307 87-010-198-080 CAP, CHIP 0.022 C308 87-010-198-080 CAP, CHIP 0.022 C309 87-010-498-040 CAP,E 10-16 GAS C310 87-010-498-040 CAP,E 10-16 GAS C311 87-A10-781-080 C-CAP,U 0.15-10 K B C312 87-A10-781-080 C-CAP,U 0.

23、15-10 K B C313 87-A10-781-080 C-CAP,U 0.15-10 K B RadioFans.CN 收音机爱 好者资料库 KANRI NO. REF. NO.DESCRIPTIONPART NO.KANRI NO. REF. NO.DESCRIPTIONPART NO. 4 ! C314 87-A10-781-080 C-CAP,U 0.15-10 K B C315 87-010-498-040 CAP,E 10-16 GAS C316 87-010-498-040 CAP,E 10-16 GAS C321 87-010-759-080 C-CAP,U, 0.1-25

24、F C322 87-010-555-040 CAP,E 100-10 GAS C323 87-010-759-080 C-CAP,U, 0.1-25F C324 87-010-498-040 CAP,E 10-16 GAS C331 87-A10-707-080 C-CAP,U 0.47U-16 F Z C332 87-A10-707-080 C-CAP,U 0.47U-16 F Z C333 87-010-759-080 C-CAP,U, 0.1-25F C334 87-010-759-080 C-CAP,U, 0.1-25F C351 87-010-494-040 CAP,E 1-50 G

25、AS C352 87-010-494-040 CAP,E 1-50 GAS C353 87-010-494-040 CAP,E 1-50 GAS C354 87-010-494-040 CAP,E 1-50 GAS C361 87-A10-707-080 C-CAP,U 0.47U-16 F Z C362 87-A10-707-080 C-CAP,U 0.47U-16 F Z C363 87-A10-707-080 C-CAP,U 0.47U-16 F Z C364 87-A10-707-080 C-CAP,U 0.47U-16 F Z C365 87-012-271-080 CAP, U 5

26、60P-50 C366 87-012-271-080 CAP, U 560P-50 C367 87-012-271-080 CAP, U 560P-50 C368 87-012-271-080 CAP, U 560P-50 C451 87-010-498-040 CAP,E 10-16 GAS C452 87-010-498-040 CAP,E 10-16 GAS C453 87-010-498-040 CAP,E 10-16 GAS C454 87-010-498-040 CAP,E 10-16 GAS C455 87-012-270-080 CAP, U 470P-50 C456 87-0

27、12-270-080 CAP, U 470P-50 C457 87-012-270-080 CAP, U 470P-50 C458 87-012-270-080 CAP, U 470P-50 C511 8A-KC7-623-000 CAP,E 2200U-16 BT(125C) C512 87-010-759-080 C-CAP,U, 0.1-25F C513 87-010-759-080 C-CAP,U, 0.1-25F C514 87-010-553-040 CAP,E 47-16 GAS C515 87-010-552-040 CAP,E 22-16 GAS C516 87-012-27

28、4-080 CHIP CAP,U 1000P-50B C519 87-010-494-040 CAP,E 1-50 GAS C531 87-A12-317-080 C-CAP,U 0.1-50 Z F C532 87-A12-317-080 C-CAP,U 0.1-50 Z F C533 87-A12-317-080 C-CAP,U 0.1-50 Z F C534 87-A12-317-080 C-CAP,U 0.1-50 Z F C551 87-010-553-040 CAP,E 47-16 GAS C590 87-012-274-080 CHIP CAP,U 1000P-50B C621

29、87-010-553-040 CAP,E 47-16 GAS C622 87-010-553-040 CAP,E 47-16 GAS C641 87-010-759-080 C-CAP,U, 0.1-25F C642 87-010-759-080 C-CAP,U, 0.1-25F C671 87-010-787-080 CAP, U 0.022-25 C672 87-010-498-040 CAP,E 10-16 M 5L SRE C673 87-010-498-040 CAP,E 10-16 M 5L SRE C674 87-010-787-080 CAP, U 0.022-25 C681

30、87-010-553-040 CAP,E 47-16 GAS C682 87-010-787-080 CAP, U 0.022-25 C701 87-012-182-080 C-CAP,U 27P-50 CH C702 87-012-180-080 C-CAP,U 22P-50 CH C706 87-010-497-040 CAP,E 4.7-35 GAS C711 87-012-195-080 C-CAP,U 100P-50CH C712 87-012-195-080 C-CAP,U 100P-50CH C761 87-010-555-040 CAP,E 100-10 GAS C763 87

31、-010-759-080 C-CAP,U, 0.1-25F C765 87-016-039-090 CAP,DL 0.022F-5.5 Z 70 FM C771 87-012-199-080 CAP 220P C831 87-010-494-040 CAP,E 1-50 GAS C832 87-010-494-040 CAP,E 1-50 GAS C835 87-012-278-080 C-CAP,U 2200P-50 B C836 87-012-278-080 C-CAP,U 2200P-50 B C881 87-012-278-080 C-CAP,U 2200P-50 B C882 87-

32、012-278-080 C-CAP,U 2200P-50 B C883 87-012-278-080 C-CAP,U 2200P-50 B C884 87-012-278-080 C-CAP,U 2200P-50 B C885 87-010-759-080 C-CAP,U, 0.1-25F CON201 87-A61-507-010 CONN,26P TKC-W26P-A1 CON851 88-KTA-603-010 CONN,15P CAM-B68 CON881 8Z-KT1-611-010 CONN,16P CAM-B51 F881 8Z-KC1-621-010 FUSE,15A 32V

33、FC201 8B-KCF-611-010 F-CABLE,2P 55MM J101 8Z-KT1-614-010 ANT,AW-002 J451 87-A61-225-110 JACK,PIN 2P XR-401 J451 87-A61-224-110 JACK,PIN 4P XR-401 L101 87-003-143-080 COIL 4.7 UH L102 8Z-KT1-619-010 COIL,68MH K7-D L461 87-003-143-080 COIL 4.7 UH L671 87-003-149-080 COIL,47UH L831 87-003-143-080 COIL

34、4.7 UH L881 8B-KCF-615-010 FLTR,AMORPHOUS -CHOKE LED702 87-027-262-010 LED,TLR-124(RED) SW701 87-A91-070-010 SW,TACT SKHHLV SW702 87-A91-152-010 SW,SL 1-1-2 SSSS212-11-A TU101 8B-KCF-621-110 TU UNIT, FAE347-A26 TU101 8B-KCF-621-010 TU UNIT, FAE347-A22 X201 81-592-641-010 VIB,CER 16.93MHZ X701 87-A70

35、-175-010 VIB,XTAL 4.5MHZ AT-49 FRONT C.B C901 87-A10-047-080 C-CAP,U 1-10 Z F C902 87-A10-504-080 C-CAP,U 0.047-16 K B C903 87-A10-504-080 C-CAP,U 0.047-16 K B C904 87-012-273-080 C-CAP,U 820P-50 B C905 87-A10-260-080 C-CAP,U 0.1-16 K B C971 87-A10-260-080 C-CAP,U 0.1-16 K B CON901 88-KTA-602-010 CO

36、NN,15P CAM-B67 LCD901 8B-KCF-610-010 LCD,BKC-F-G-H LED951 87-A91-355-040 C-LED,BR1112H-TR-RED LED952 87-A91-355-040 C-LED,BR1112H-TR-RED LED961 87-A40-813-240 C-LED,SEC1E01C BLU LED962 87-A40-813-240 C-LED,SEC1E01C BLU LED963 87-A40-813-240 C-LED,SEC1E01C BLU LED981 87-A91-355-040 C-LED,BR1112H-TR-R

37、ED LED982 87-A91-355-040 C-LED,BR1112H-TR-RED LED983 87-A91-355-040 C-LED,BR1112H-TR-RED PL901 8B-KCF-631-010 LAMP,9V-65MA PL902 8B-KCF-631-010 LAMP,9V-65MA SW901 87-A91-987-080 SW,TACT SKQCAB SW902 87-A91-987-080 SW,TACT SKQCAB SW903 87-A91-987-080 SW,TACT SKQCAB SW904 87-A91-987-080 SW,TACT SKQCAB

38、 SW905 87-036-339-080 C-SW,TACT SKQMAH SW906 87-A91-987-080 SW,TACT SKQCAB SW907 87-A91-987-080 SW,TACT SKQCAB SW908 87-036-339-080 C-SW,TACT SKQMAH SW910 87-036-339-080 C-SW,TACT SKQMAH SW911 87-A91-987-080 SW,TACT SKQCAB SW913 87-036-339-080 C-SW,TACT SKQMAH SW914 87-A91-987-080 SW,TACT SKQCAB SW9

39、15 87-036-339-080 C-SW,TACT SKQMAH SW916 87-A91-987-080 SW,TACT SKQCAB SW917 87-036-339-080 C-SW,TACT SKQMAH SW918 87-A91-987-080 SW,TACT SKQCAB SW921 87-A91-986-010 SW,RTRY EC12E24504-15MM AUX C.B FFC901 8A-KC7-611-010 F-CABLE,3P (AUX) J901 85-HRL-623-010 JACK,3.5 ST BLK CONN.C.B C1 87-A11-062-080

40、C-CAP,S 2.2-16 ZF KANRI NO. REF. NO.DESCRIPTIONPART NO.KANRI NO. REF. NO.DESCRIPTIONPART NO. 5 8 8 A Resistor Code Chip Resistor Part Coding Figure Value of resistor Chip resistor WattageTypeTolerance 1/16W 1/10W 1/8W 1608 2125 3216 5% 5% 5% CJ CJ CJ FormLWt 1.60.80.45 21.250.45 3.21.6 108 118 128 :

41、 A : A CHIP RESISTOR PART CODE 0.55 Resistor Code Dimensions (mm) Symbol 1/16W10055%CJ1.00.50.35104 L t W TRANSISTOR ILLUSTRATION B C EB C EE C B 2SA1037 2SC2412 DTA114TKA DTC114EKA DTC114YKA DTC114TKA DTC144EKA 2SB1375 2SD2012 2SB1326 2SD1862 CN1 87-A61-718-080 C-CONN,26P V TKC-W26X-A1 SW C.B S1 87

42、-A92-279-080 C-SW,PUSH 2-1 ESE22MH22XQ S2 87-A92-279-080 C-SW,PUSH 2-1 ESE22MH22XQ FLEX.C.B 8B-ZG3-603-010 PWB,FLEX PIC WIRING 1 (MAIN) 3231302928272625242322212019181716151413121110987654321 6 A B C D E F G H I J K L M N O P Q R S T U WIRING 1 (MAIN) 123456789101112131415161718192021222324252627282

43、9303132 7 A B C D E F G H I J K L M N O P Q R S T U ? ? ? ? WIRING 2 (FRONT / AUX) 3231302928272625242322212019181716151413121110987654321 10 A B C D E F G H I J K L M N O P Q R S T U WIRING 2 (FRONT) 1234567891011121314151617181920212223242526272829303132 11 A B C D E F G H I J K L M N O P Q R S T

44、U ? ? ? 123456789101112131415 A B C D E F G H I J K L M N O P Q R S T U ? 13 1315 C1 1113597 11 26242220181614 97531 ? ? 1 15 MECHANICAL EXPLODED VIEW 1 / 1 1 2 3 4 5 6 7 8 9 10 11 12 A 13 14 15 1617 18 19 20 21 22 23 24 25 26 27 28 LCD SH,LCD 29 30 31 32 33 PWB B B 34 37 35 36 38 39 40 C D D HLDR,H

45、ALF-C 41 D D E E 42 HLDR,TR2-AC BZG-3,YANF HLDR,MECHA AS-BC E E E 43 COVER,TOP-C C E E E F G PWB E SH,PWB C H E E COVER,BOTTOM-C HLDR,P-IC-AC PANEL,HT-SINK F-CABLE,2P 55MM FUSE 16 MECHANICAL PARTS LIST 1 / 1 DESCRIPTIONREF. NO.KANRI NO. PART NO.DESCRIPTIONREF. NO.KANRI NO. PART NO. COLOR NAME TABLE

46、Basic color symbolColorBasic color symbolColorBasic color symbolColor BBlackCCreamDOrange GGreenHGrayLBlue LTTransparent BlueNGoldPPink RRedSSilverSTTitan Silver TBrownVVioletWWhite WTTransparent WhiteYYellowYTTransparent Yellow LMMetallic BlueLLLight BlueGTTransparent Green LDDark BlueDTTransparent OrangeGMMetallic Gre