Teac-X-01-Service-Manual电路原理图.pdf

《Teac-X-01-Service-Manual电路原理图.pdf》由会员分享，可在线阅读，更多相关《Teac-X-01-Service-Manual电路原理图.pdf（41页珍藏版）》请在收音机爱好者资料库上搜索。

1、X X- -0 01 1 SERVICE MANUAL SUPER AUDIO CD PLAYER Effective : September, 2004 8C0365S-0128A NOTES PC boards shown are viewed from parts side. The parts with no reference number or no parts number in the exploded views are not supplied. As regards the resistors and capacitors, refer to the circuit di

2、agrams contained in this manual. Parts marked with this sign are safety critical components. They must be replaced with identical components - refer to the appropriate parts list and ensure exact replacement. CONTENTS 1 SPECIFICATIONS 2 2 ADJUSTMENTS 3 3 EXPLODED VIEWS AND PARTS LIST 4 4 PC BOARDS A

3、ND PARTS LIST 10 5 INCLUDED ACCESSORIES 22 For U.S.A. RadioFans.CN 收音机爱 好者资料库 1 SPECIFICATIONS 2 General System.SACD and CD Power supply .AC 120 V, 60 Hz Power consumption .40 W Weight.25 kg (55-1/16 lb) External dimensions (W x H x D) .442 x 153 x 353 mm (17-3/8 x 6 x 13-7/8) Operating temperature.

4、+5C - +35C Operating humidity.5% to 85% (no condensation) Storage temperature .20C - +55C Audio output (Analog Audio) Jacks.XLR jacks (2 channel) x 1 RCA jacks (5.1 channel) x 1 Maximum Output level (1 kHz, full scale) .2.5 Vrms (RCA) 2.3 Vrms (XLR) Nominal Output level (1 kHz, full scale 20dB).250

5、mVrms (RCA) 230 mVrms (XLR) Frequency response .5Hz - 58 kHz (SACD) Signal-to-Noise Ratio (S/N).112 dB (SACD, 1 kHz) Dynamic range .106 dB (SACD, 1 kHz) Total harmonic distortion.0.001% (SACD, 1 kHz) Audio output (Digital Audio) OPTICAL .Optical digital jack x 1, 15 to 21 dBm COAXIAL .RCA jack x 1,

6、0.5 Vp-p/75 Word Synchronization input format Jack .BNC Input level .4.5 Vp-p/75 The main unit can accept and synchronize to the following frequencies received from external devices: 44.1kHz, 88.2kHz, 176.4kHz Accessories Power cord x 1 Remote Control Unit (RC-941) x 1 Batteries (AA, R6, SUM-3) x 2

7、Screwdriver x 1 Felt x 3 Warranty card x 1 Owners manual x 1 Design and specifications are subject to change without notice. Weight and dimensions are approximate. 353mm 332mm153mm 442mm RadioFans.CN 收音机爱 好者资料库 2 ADJUSTMENTS 3 2-1 Sled Offset Adjustment 1. Connect the probe of oscilloscope to pin 1

8、(SLCNT) of P205 on CORE PCB, and the probe earth to pin 2 (SL18V). 2. Set the oscilloscopes voltage range to DC100mV, and the time calibration to 10mS. 3. Adjust potentiometer R232 for a potential difference of 0V between pins 1 and 2. 2-2 Sled Gain Adjustment 1. Connect the probe of oscilloscope to

9、 pin 3 (H1OUT) of P205 on CORE PCB, and the probe earth to pin 2 (SL18V). 2. Set the oscilloscopes voltage range to AC200mV, and the time calibration to 10mS. 3. Press the DF range button on RC-668 (P/No. E00380000A), a remote controller for VRDS-8, to activate the sled, and adjust potentiometer R23

10、5 for a sine wave output of 1Vp-p at pin 3. Pressing the DF range button again beings the unit back to the normal mode. R232 R235 CORE PCB P205 (Bottom Side) SAFETY INFORMATION This product has been designed and manufactured according to FDA regulations title 21, CFR, chapter 1, subchapter J, based

11、on the Radiation Control for Health and Safety Act of 1968, and is classified as a class 1 laser product. There is no hazardous invisible laser radiation during operation because invisible laser radiation emitted inside of this product is completely confined in the protective housings. The label req

12、uired in this regulation is shown 1. OCAUTION USE OF CONTROLS OR ADJUSTMENT OR PERFORMANCE OF PROCEDURES OTHER THAN THOSE SPECIFIED HEREIN MAY RESULT IN HAZARDOUS RADIATION EXPOSURE. Optical pickup: Type: GH20707A2A Manufacturer: SHARP CORPORATION Laser output: Less than 1mW on the objective lens Wa

13、velength: 7885 nm (CD) 1For U.S.A. 3 EXPLODED VIEWS AND PARTS LIST EXPLODED VIEW-1 4 1 2 3 4 8 9 t y u i p s d f g h a j k k m , / $ % Q E ( T ) Y U I R H P S D F G G T 0 w w q e r l l ; z z z x x x c v b n V V 7 K K C B 5 6 J L A O A 6 J T A B W Z X . : K B B 5 EXPLODED VIEW-1 REF.NO.PARTS NO.DESCR

14、IPTIONREMARKS 1- 1M01724000ATOP PANEL,X-01 1- 2M01777500ACUSHION,FOAM TOP 1- 3M01766810AFRAME,TOP R EXP 1- 4M01766710AFRAME,TOP L EXP 1- 5M01648100BSIDE PANEL,L 1- 6M00387502ACOLLAR,SCREW(N01SP) 1- 7E95182300APCB ASSY,POWER 1- 8M01724500APLATE,PCB PWR 1- 9M01766900ABRACKET,MECHA 1-10M01839400APOLYES

15、T SH,MECHA T0.25 1-11M01839500APOLYEST SH,MECHA T0.35 1-12M01782900ARUBBER SH,BRACKET 1-13M01719000AMECH ASSY,UNIT 1-14M01712700APANEL,TRAY X-01 1-15M00389310BCHASSIS,SIDE L EXP 1-16 E00857220ATRANS,ANALOG T/C 1-17 E00857120ATRANS,DIGITAL T/C 1-18M01724400ACHASSIS,TRANS 1-20M01724210AFRAME,L EXP 1-2

16、1M01724310AFRAME,R EXP 1-22E95182500APCB ASSY,PSW 1-23M01724110ACHASSIS,FRONT EXP 1-24E95182000APCB ASSY,PWRLED 1-25E95181900APCB ASSY,FRONT 1-26M01838900BRUBBER SH,PORON T5 135X15 1-27M01723600ABUTTON,D10 1-28M01723500ABUTTON,D8 1-29M01717600BCUSHION,PORON T3 105X12 1-30M01723800ALENS,D10 1-31M0172

17、3900ABRACKET,LENS 1-32M01723700ALENS,D8 1-33M01722700AFRONT PNL ASSY,X-01 1-34M01723300BWINDOW,FRONT 1-35M01723400APLATE,BLIND 1-36M01777600ACUSHION,FOAM FRONT 1-37M01480700AHEATSINK 1-38E95182400APCB ASSY,REG 1-39M01723120AREAR PANEL,T/C 1-40E00768700ATERMINAL,GND D12 1-44E95182600APCB ASSY,INLET 1

18、-45M01781200ACOVER,PLATE REAR 1-49M01259600APOLYEST WSHR,10.5X20X0.2T 1-50E95182100APCB ASSY,D-OUT 1-51E95181100APCB ASSY,DAC 2CH A-L 1-52E00862300AFLAT CABLE,DAC2-DAC4 1-53E00862100AFLAT CABLE,CORE-DAC2 1-54M01480201ABRACKET,PCB 1-5516359645SPCR,SQ-50 1-56E95191800APCB ASSY,DAC 4CH A 1-57M01724700A

19、BRACKET,SIDE 1-58M00389410ACHASSIS,SIDE R EXP 1-59M01648200BSIDE PANEL,R 1-60M01781100BRUBBER SH,BOTTOM 1-61M01724600APLATE,BOTTOM 1-62M01494802AFOOT(A) HEX 15 6 EXPLODED VIEW-1 REF.NO.PARTS NO.DESCRIPTIONREMARKS 1-63M01495001ASTAND,FOOT 13 1-64M01494901AFOOT(B) 11 1-65M01839300BSPACER,ZNC M4X4 1-66

20、E95181200APCB ASSY,DAC 2CH A-R 1-67M01939700AGASKET,E02F4T/3X310 1-68M01571300ASHEET,SHIELD(CU)-10 1-69E0096620CORE,E04SR130525AB BLACK 1-70M01939800AGASKET,E02F4T/5X420 1-71M01937300ASHRINK SHIELD,20X180 1-72E0096950CORE,E04FG221308 1-73E0081410CORE,E04RC281613 1-74M01939600AGASKET,E02S080030ET/50M

21、M 1-75M01847300ARUBBER SH,D9XT2 PORON 1-815801532510SCREW,HEXAGON 3X8SILVER 1-82B00132900ASCREW,VPC 3X6FZC 1-83B00132600ASCREW,VPB 3X8FZC 1-84B0010020SCREW,PPSU 4X8FNB 1-85B00090900ASCREW,VPBR 3X8FNB 1-865780003004SCREW,BPA 3X4FZC 1-875780003006SCREW,BPA 3X6FZC 1-885783613008SCREW,VPCR 3X8NB 1-89B00

22、132901ASCREW,VPC 3X8FZC 1-905780122610SCREW,PAN M2.6X10NB 1-915781702606SCREW,HEXAGON M2.6X6(NI) 1-935801148000SCREW,BIND M3X4(BLK) 1-945783113006SCREW,ZPAT 3X6NB 1-955780012004SCREW,BPA M2X4FNI 1-965780013003SCREW,BPA 3X3FNI 1-975780024008SCREW,BPA 4X8FNB 1-98B00197708ASCREW,PPSU 4X8FZB G EXPLODED

23、VIEW-2 7 1 2 3 4 5 6 6 7 8 9 9 q q q w e r t y u i o p a s d f h j k l ; z x c v v v v b b n n m m , . / ! Q ( S D F F H H H K K K K L A A 6 / 6 u i ) W $ E R T 7 5 6 0 G K K K K K K K K K K K J J g % Y K K G G : # August 2004 PCBA,POWER PCBA,CORE PCBA,FRONT PCBA, DAC2CH L PCBA,REG PCBA, DAC2CH R PC

24、BA,INLET TRANS,ANALOG TRANS,DIGITAL PCBA,PSW J02 P01P02P03 P06 P15 P14 P07 P08 P12 P11 P10 P09 P16 P401 PICKUP UNIT PCBA,SW-JOINTPCBA,SPDL SLED MOTOR P101P201 P1 P7P9 PCBA,PWRLED P1303 P1302 P1301P1304 P1305 P1306 P1301 P1302 P1303 P1004P1004 PCBA,D-OUT P1003 P602 P1001P801 P1503P803 P1004 P1501 P4

25、P5 P1005P1502 P701 P2 P203P202P204 P151P103P104 PCBA,DAC4CH P1304 P1305 P1306 P2501 P2502 P2503 P1003 P2001 86745231 E D C B A WIRING DIAGRAMX-01POWER SUPPLY SUPER AUDIO CD PLAYER X X- -0 01 1 2 nd Issue; August 2004 -35V_2 P8V +8VD PCBA,POWER -35V_1 P12V -8VA F5V VIN2 10V (A) GND (14.5C) B5V +8VA V

26、IN1 GND (17.5A) 14.5V (CORE) PCBA,CORE 17.5V_1 (A) GND (10.5C) F5V GNDA2 TRANS,ANALOG 14.5V (V)10.5V (CORE) +5V GNDA1 7.5V_2 (V) 7V (CORE) FL_-30V GND1 -15VA GND (14.5V) GND (7C) TRANS,DIGITAL /RESET +15VA GND (V) /P_DOWN FL_AC1 PCBA,REG 7.5V_1 (V)GND (7VF) BGND FL_AC2 FL_AC2 LIVE NC 2.8VAC_CT 7V (V

27、 August 2004 BDGND DIV_WORD GND DSD_FR VCXO_SEL IF_SCK DIV_SEL1 MUTE2 PCM_SL/SR DSD_EN 768Fs2 SDO BCK GND PCMLRCK SCKMI GND TM_DATA CDDASEL SDO C/SW DF MUTE GND RESET ASEL2 Fs SEL2 BE_DATA IF_DATA GND BE_DATA GND DGND DIV_WORD DGND GND GND GND 768Fs2 1394EN GND TP1028 GND DEMP Fs SEL1 GND Fs SEL2 DI

28、V_SEL1 4FS_EN TP1022 TP1032 LED_POWER WORD_ON GND GND DSD_SL GND DSD_C GND BE_READY EN_DSD DSD_BCK SDO SL/SR DGND 44_EN GND IF_SCK 27M_IN RESET BDGND GND DOUT0 (5V) TP1029 BE_READY GND DSD_SEL 27MOUT2 A MUTE GND DIV_SEL0 PLL_ERROR SCKMI DIV_SEL0 IF_DATA 4448_SEL SDO FL/FR AMUTE2 SDO SL/SR Fs SEL2 RE

29、SET Fs SEL1 GND WORD_IN TP1024 GND SDO C/SW FM_DATA GND GND TP1001 PCBA,DAC 4CH GND GND PCBA,FRONT TP1025 GND 4FS_EN GND EMP SDO WCK DSD_SW AMUTE1 SDO SL/SR 1394_EN 2FS_EN CLKA_SEL GND GND DSD_SR PLL_ERROR A MUTE GND TP1027 GND GND GND GND TP1026 PCBA, PWRLED 1394_EN GND PCBA,DAC2CH L SDO BCK DF MUT

30、E CLKA_SEL PCBA,D-OUT FFC_15P 4448_SEL GND PCMBCK A2_RST CDDASEL GND GND GND SDO C/SW GND GND BD5V GND GND TXDMI DSD_FL +5V 1394_EN LED_POWER IF_REQ VCXO_SEL IF_REQ DOUT0 (5V) MUTE_LR SDO WCK TP1030 ASEL1 SDO BCK GND MUTE1 GND 44/48 FFC_40P PCM_C/SW +5V GND MUTE_LR DSD_EN GND PCM_FL/FR IFRM RXDMI +5

31、V TP1023 WORD_ON PCBA,CORE INACO SDO WCK P1005 B3B-PH 1 2 3 P1001 40FLT-SM1-TB 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 P1004 B2B-PH-RED 1 2 P7 B3B-PH 1 2 3 P5 B3B-PH 1 2 3 P801 40FLT-SM1-TB 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16

32、17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 P1502 B10B-PH 1 2 3 4 5 6 7 8 9 10 P9 B3B-PH 1 2 3 P701 S9B-ZR-SM3A 1 2 3 4 5 6 7 8 9 P602 S4B-PH-SM3 1 2 3 4 P2 B9B-PH 1 2 3 4 5 6 7 8 9 P1003 15FMN-BTK-A 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 P2001 15FMN-BTK-A 1 2 3 4 5 6 7 8 9

33、10 11 12 13 14 15 P4 B10B-PH 1 2 3 4 5 6 7 8 9 10 P803 S2B-PH-SM3 1 2 P1501 B2B-PH-RED 1 2 P1503 B2B-PH 1 2 P1003 B4B-PH 1 2 3 4 PCBA,DAC2CH R WCK 2WCK 2 GNDD GNDD GNDD GNDD GNDD GNDD BCKOBCKO DORDOR A_MUTEA_MUTE P1004 B7B-PH 1 2 3 4 5 6 7 P1004 B7B-PH 1 2 3 4 5 6 7 86745231 E D C B A WIRING DIAGRAM

34、X-01MECHA SECTION SUPER AUDIO CD PLAYER X X- -0 01 1 2 nd Issue; August 2004 SPA3 H1+ H- PPGND E NC F PCBA,SPDL GND SPA2 H1+ H+ B T- VCC VCC PCBA,SW-JOINT SPA1 GND OPN_SW F- LD(CD) GND CL- B SLA3 GND TRY- CLS_SW C RF VC CL+ C PCBA,CORE SLA2 H+ FD3.3V NC GND LMT_SW D SLA1 H- OUT_SW T+ TRY- GND HA5 GN

35、DGND LMT_SW D FPGND TRY+ NC HA4 H3- GND TRAY_FG PD FFC_9P NC CL- VOL HA3 H3+ GND FD3.3V FFC_23P TRAY_FG CL+ F- HA2 FPGND FFC_15P CU_SW PPGND VOL F+ PD HA1 VOL GND H1- CLS_SW CD_SW VCC A T+ SLED MOTOR PICKUP UNIT SPA1 LD(DVD) H2-H2- CD_SW VC VOL LD(DVD) SPA2 H2+H2+ TRY+ A E T- GND H3+ OPN_SW F GND PD

36、 RF SPA3 H1- H3- OUT_SW VCC PD LD(CD) F+ CU_SW PCBA,PHOTOINT TRAY_FGTRAY_FG FD3.3VFD3.3V GNDGND GRY PUR TRY+ TRY- BRN REDCL+ CL- PCBA,C-MOTOR PCBA,T-MOTOR CLMP-SWOUT-SWLMT-SWOPEN-SWCLS-SW GRN BLU BRN RED ORG YEL P156 B2B-ZR 1 2 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 P171 B2B-PH

37、1 2 T-MOTOR P160 B2B-PH 1 2 P157 B2B-ZR 1 2 P196 S3B-ZR 1 2 3 P159 B3B-ZR 1 2 3 MOTOR3 P151 15FMN-STK 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 P104 S3B-PH-SM3 1 2 3 P172 B2B-PH 1 2 P152 B2B-PH 1 2 P201 00_6232_109_103_800 1 2 3 4 5 6 7 8 9 P153 B3B-ZR 1 2 3 P154 B2B-ZR 1 2 P202 S12B-ZR-SM3A 1 2 3 4 5 6 7

38、 8 9 10 11 12 P204 00_6232_115_103_800 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 P155 B2B-ZR 1 2 P203 S3B-PH-SM3 1 2 3 P101 00_6200_237_032_800 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 P103 S12B-ZR-SM3A 1 2 3 4 5 6 7 8 9 10 11 12 86745231 E D C B A SCHEMATIC DIAGRAMX-01CORE PCB (1/8) (R

39、F AMP), SW-JOINT PCB, C-MOTOR PCB, T-MOTOR PCB, PHOTO INT PCB SUPER AUDIO CD PLAYER X X- -0 01 1 2 nd Issue; August 2004 2 3 3 3 3 3 3,5 3 3 3 3 2 3 2 3 2 VOL PD LD(CD) GND NC F- T+ T- F+ B C D A E F VCC VC GND VOL PD LD(DVD) RF VCC 3 2 (BOTTOM_CONTACT) CD/XDVD RFOP FAGND B C LD_DVD A PD DVD A MIRR

40、C B VC25 PD CD FA5V D LDON D FA5V F VC25 LD_CD FAGND FAGND B C D A E F PD_DVD LD_DVD E RFOP F- AMPSCK AMPMNT CD/XDVD AMPSEN MIRR DFCT F+ T- PI T+ TE0 LDON RFAC FE0 AMPSDT FA3.3V FAGND FAGND FA3.3V FAGND FAGND FAGND FA5V FA5V FDGND FAGND FA5V FA5V FA5V FD3.3V FAGND FAGND VC16_2 VC16_1 FAGND FA5V FAGN

41、D FAGND T104FAGND T122 C T142 RFP T105NC C1401000p T129 CE R128 100K C1360.047u R1151K C103 0.01u T138 RFSIN C1202200p C1250.01u RA101 RAC1608-1524DJT 18 27 36 45 T103 LDCD C1134700p T101VOL + C110 10u/16V 12 + C134 10u/16V 12 C11522p + C13810u/16V 12 C1222200p C1330.01u T113VCC Q102 2SK3019 R103100

42、 +C109 47u/6.3V 12 T123 D T125MLPF T119 IOP_CD R129 100K C131 1u(2125) Q104 2SB1132 12 3 C1450.1u + C12610u/16V 12 C1192200p C1420.1u T130 VC16 T114VC P101 00_6200_237_032_800 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 C102 0.01u Q103 2SK3019 + C111 10u/16V 12 C1270.033u R122 33 T10

43、2PD T131 DFCT R1250 T136 AIP + C107 10u/16V 12 T126MB T150 NC T107 C C1240.01u T120 A C1370.1u L101 47uH/LQH32CN C1440.1u T144 LDON T115PD T112 VOL T133 AMPSDT C1430.1u T146 FAGND T143 RFN Q105 2SB1132 12 3 R12733K C1350.01u T135CD/XDVD C11822p T141RFAC T137 AIN C1280.033u Q101 2SK3019 T127MP C1410.

44、1u T110 E C1320.01u T109 A R10112K(1%) C130 NM C11722p U101 CXD1881BR 1 64 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 DVDRFP RFDC DVDRFN A2 B2 C2 D2 CP CN D C B A CD

45、_D CD_C CD_B CD_A CD_F CD_E VPB VC DVDLD CDLD DVDPD CDPD VNB LDON MIRR MP MD MLPF MIN MEVO LINK DFT TPH V125 V25 PI TE FE CE MNTR LCN LCP V33 SCLK SDATA SDEN RX MEV VNA FNN FNP DIP DIN BYP RFAC VPA AIP AIN ATON ATOP RFSIN L102 47uH/LQH32CN P102 B3B-ZR-SM3 1 2 3 T118 IOP_DV R111 33 T132 AMPSEN T145 M

46、IRR T140 RFOP T117 RF T121 B T134 AMPSCK C146 0.1u +C105 47u/6.3V 12 + C104 22u/16V 12 T124MIN C108 1000p R112 33 C112 1000p R12633K C1212200p R1241K + C106 10u/16V 12 R123 33 R102100 T111 F T106 B T108 D C101 0.01u C129150p C1144700p R104 10K T128 LINK C1390.01u T116LDDVD C11622p T139 RFDC C123330p CLMP-SW OPN_SWCLS_SWOUT_SWLMT_SW TRY_FG CU_SW CLS_SW TRY+ FPGND CL+ LMT_SW CD_SW TRY- CL- FPGND NC FD3.3V OPN_SW OUT_SW RED ORG FPGND TRY_FG 1 34 FD3.3V 2 YEL GRN BLU BRN RED BRN